Problems with 2004 Ford F-150 EXTERIOR LIGHTING

With headlight selector switch in the auto position the headlights can suddenly turn-off while driving. i purchased the vehicle new and have always had the headlight switch in the auto position since day one. when driving at night the headlights suddenly shut-off while going down the highway, very nearly lost control of vehicle when trying to pull over and stop. the park lights still were functioning and got the headlights back on by switching the headlight switch to the manual position. per discussion with dealer believe the body control module quit working. specifically, a relay in the bcm has failed but is not replaceable. repair cost is over $400.00 to change module. can't afford right now to fix. research on internet found numerous other similar failures/symptoms but not clear if happened while vehicle was being driven. *tr

To begin with i had to have all 4 windows repaired. the mechanism that raises and lowers the windows broke. since this was bought as a used vehicle, there was no warranty. so i pd. $150. to $175.00 each. was told ford knew of this problem but since it wasn't a "safety factor" no recall was issued. i feel like this is quite unfair to the consumer. we purchase a vehicle that has a good reputation and then are told that this expense is our baby to take care of. i feel like this was very unfair to this consumer. i have purchased fords for years with no complaints until now. also, the headlights developed a leak and filled with water thus shorting out my right headlight,and is slowly doing the same to the left one. i have been told that just the burned out bulbs cannot be replaced,that the whole assembly had to be replaced and this is at a cost of approx. $175 to $200. per assembly. this is outrageous. also,there is a problem with what used to be "points & plugs" which are now a "coil" assembly. this problem developed approx. 6 months ago. according to the readouts i have gotten, the #1 plug is misfiring approx. every 1,000 revolutions which causes a miss in the engine and was very alarming to me since i was on the highway about 200-250 miles from home, traveling by myself. so, another expense is looming. i realize there are expenses to owning a vehicle. i do not expect to not have any problems or repairs with my vehicle,but i did not anticipate this many. nor did i expect the cost of the repair parts alone to be so outrageous. i am on a fixed income and had i anticipated these problems i wouldn't & #8203; have made this purchase. i truly love my truck, but is there anyway these other repairs can be done for a lesser amt? i've already pd. to replace motor & rotors in all 4 windows. any help you can give me would be greatly appreciated. thank you. [xxx] ('parts of this document have been redacted to protect personally identifiable information pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).'

I own a 2004 ford f-150. in 2012 i had my e-brake light start flashing at me. i brought it into the mechanic and had them look it over, they said they couldn't find anything wrong other then the wiring under the dash was probably bad, so i brought it to a brake specialist and they said the same thing, nothing wrong with cylinder or brakes, that it was the wiring under the dash. i'm truly not safe using my e-brake as i'm not sure if it is working or not. my interior lights started coming on also when i would turn on my headlights, everyone knows you shouldn't have the interior lights on while driving at night anyway. i have read several articles where other ford f-150 owners are having the same problems. i think this needs to be looked into and a recall should go out. *tr

2004 ford f150 w/ adjustable pedals - after a few years use, the brake lights do not work properly. the lights will come on, but only under extreme deceleration, hopefully. the lights will reset if the brake switch is unplugged and plugged back in with vehicle running, but then will continue to act unreliably after a few days of use. the brakes continue to work along with the switch to reposition the automatic shifter from out of park, but the brake lights are completely unreliable. i visit an official ford f150 forum with many other members that several others are starting to notice that their trucks are doing the same thing. replacing the "brake switch" recommended by ford did not correct this problem. this problem has been reported on the forum by members with 2005 and 2006 models as well. *tr

I have three ford and hadn't been notice about any recall on my ford f150 2004 and 2007. *tr

Passenger side driving/fog light reflector looks rusted/ fast forward to july 9th, 2014 the whole reflector bracket is rusted sitting on the bottom of this lighting housing. item was reported just after warranty period was over and item was never corrected with ford. this housing was defective from the day i purchased this vehicle new. *tr

Tl*the contact owns a 2004 ford f-150. approximately 3 years ago, the rear passenger side brakes began to vibrate. the failure occurred at various speeds. the vehicle was taken to the ford dealer 5 times before a repair was finally made. currently, the driver side is experiencing the same failure. the abs is locking the tires in a certain spot and preventing them from properly turning. the consumer stated the abs seemed to randomly activate on 1 wheel. the turn signal did not always cancel after making a turn. updated 12/05/07

The 2004 f150 sc has a few problems: first was the water leaking from the third brake light in which i had to apply silicone around the rubber seal of the light...never leaked again. second issue was far more frustrating, when traveling around 40 to 50 mph when deciding to accelerate quickly the truck would act as if it was being starved of fuel. the best way to describe it was by depressing the accelerator and releasing it very quickly. i took it to the wonderful ford dealership, sarcastic, and they told me nothing was wrong, and shop manager told me it was because of cold air intake... finally ,after calling ford customer service and complaining the dealership decided it was my throttle body...naturally all my problems were gone. now, less than a year later the problem arose again and i will post the outcome once known. the third incidence was the front bucket seats, started noticing shredded foam under the front part of the seats, not knowing what it could be i assumed it was excess foam around the seat straps located under each seat, to my surprise a hole appeared on the driver's seat on the front left corner facing the door and again i went to the wonderful dealership and i showed them there was a piece of metal with a sharp barb that was slowly shredding the foam and was the culprit in creating the hole and the shredded foam. caution!!!!!! if your truck has this problem be careful!!! i was getting out of the truck and the metal barb caught my pants and tore a huge hole and gave me a pretty deep cut on the inner thigh. none the less the dealership didn't do anything about it. i finally convinced them to replace the seat with me paying for the replacement cost...but, before i could get the work done the wonderful dealership went out of business and i haven't hit-up the new owners. *ak

2004 f150 right fog light replaced, front kick panel cracked and loose. *ts ***nar*** the floor trim on the passenger side came apart. the vehicle would not start. the check engine light illuminated. the oil pressure read zero. the temperature gauge failed. *nm

I honestly do not know what is wrong with my 2004 f150 fx4. my truck has been in the shop at both lincoln/mercury and ford dealers here in huntsville, alabama. parts have been replaced on multiple occasions so i'm not making this stuff up and the dealerships know something is wrong, but does not want to fix the problem or does not have qualified/trained mechanics. this will be my one and only ford. *jb

Turn signals fail intermittently. sometimes hitting the brake pedal, jiggling turn signal switch or parking, putting the vehicle in "p" then into "d" will get the signals to work. dealer cannot duplicate the problem (hence the intermittent), but the problem is not fixed. dealer will not replace parts. the problem began oct. 2005 and continues. the signals will work for days at a time, then fail for hours at a time. this is an accident and traffic citation waiting to happen. *jb

A chatter/ vibration in the rear- clutches in the rear were replaced. check engine light came on- replaced the fuel vapor management system. brake light on roof leaking- light was replaced. roof of truck rusting- nothing done. *jb

Dt: had to put 4 sets of brakes on vehicle since purchasing the car. the rotors were getting grooved so badly that vehicle pulls off the road. the consumer talked to ford, and they ignored him. he traveled and saw this problem with several other ford cars. ford told him it was cosmetic. *ak while on the first trip with this vehicle, the rear end had gone out, the clutch pack was removed and replaced, the fog lamps were holding moisture and were replaced, the brakes would pulsate and pull from one side, the shifting was harsh when changing from first to second gear, a loud clunk would be present at times when starting from stop then decelerating and the vehicle would crank but would not start at times. sc

Driver's side tail light has water (moisture) in it. *nm

The emission light came on. the vehicle was taken to the dealer, and consumer was told that fuel pump was defective. the gauge went out of control. after filling the tank, the gauge read empty. *ak the brake light wiring was inoperative, alignment was out, the vehicle had stuck in park, the right passenger door was inoperative, the speedometer read wrong, and the vehicle would die out. *sc

First applaction of brakes after backing out of drive way that is stopping at the red light at (rt)#30-& main rd,brake lines at abs control manfold,are vibrating so bad it sounds like the fan is rubbing somthing my experance with hydraulic. tells me that the brake line fittings at there seat in the manafold will fali.#2 this truck has delux mirrors,signal mirrors,led mounted in the bottom,r/s led outer three cant be seen from the driver's seat. *ak

While driving vehicle stopped accelerating. vehicle was towed to the dealership, who indicated that automatic transmission line broke. dealership repaired the line. a month later, the problem recurred. *ak dealer also replaced fuse for the back-up sensor. also, vehicle's tail lights doesn't work. *ak