Below you may see the FUEL SYSTEM, GASOLINE components and the number of complaints they received.
U.s. department of energy u.s. department of transportation this is a request for inspections, compliance, on potential safety hazards, health h...
Tl*the contact owns a 2006 ford fusion. while driving 60 mph, the vehicle would decelerate to 25 mph. the failure occurred during acceleration and c...
2006 ford fusion fails to start or even crank trying to start. been to 3 different ford dealerships in 3 states, ohio, md., and now illinois. all sa...
Tl* the contact owns a 2015 ford fusion. the contact stated that upon starting her vehicle, the vehicle began smoking from the tailpipe and was emitting a gas odor. the contact was unaware if any warning lights illuminated on the vehicle. the contact had the vehicle towed to tindol ford located at 1901 e franklin blvd, gastonia, nc 28054 where the vehicle was diagnosed with a defective injector which caused the fuel to seep through the injector and mix with the oil, causing the failure. the vehicle had not been repaired after the diagnosis. the manufacturer had been notified of the failure. the failure mileage was approximately 60,000. *dt*jb
2011 ford fusion. consumers writes in regard to vehicle being unable to ungergo safety recall repairs and having many malfunctions. *as the consumer stated engine, fuel system, and steering all malfunctioned and the dealer refused to repair the vehicle. *js
I purchased a 2011 ford fusion on 12/14/16. it had a half tank of gas in it when i took delivery. i filled the tank on 12/15/16. after driving it, i noticed a strong smell of fuel for about the top 1/8 of the tank. due to a lot of snow and ice we have had, i have not been able to tell if there is actually any fuel leaking onto the ground but the odor is there once the car is parked after driving. there is a known recall of almost a half million 2010/2011 ford fusions and mercury milans for this exact problem. my vehicle was manufactured within the dates of the recalled vehicles. i contacted ford and they stated that my vehicle is not part of this recall. they are not willing to assist me with diagnostic testing or repair at this time. they informed me that i should file a complaint regarding my situation with nhtsa. i would greatly appreciate any assistance you could offer with having my vehicle included as part of this recall. i have two young children and need a safe vehicle to be able to transport them in daily. i ...
Tl* the contact owns a 2011 ford fusion. the contact stated that while driving at 40 mph, the "check fuel fill inlet" was displayed across the message board. the vehicle was taken to a dealer where it was diagnosed that the vehicle needed to be inspected under nhtsa campaign number: 15v793000 (fuel system, gasoline) but, no trouble codes were discovered. the vehicle was not repaired however, the failure recurred and the vehicle was taken back to the dealer where it was diagnosed that the purge valve needed to be replaced. the vehicle was not repaired. the manufacturer was notified of the failure. the failure mileage was 95,000. ...updated 10/19/16 *bf *tr
Tl* the contact owns a 2011 ford fusion. the contact received notification of nhtsa campaign number: 15v793000 (fuel system, gasoline); however, the part to do the repair was unavailable. the contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. the manufacturer was made aware of the issue. the contact had not experienced a failure. the failure mileage was 75,000. updated 04/06/16*lj
Tl* the contact owns a 2011 ford fusion. the contact stated that there was an odor of fuel coming from the vehicle. the vehicle was not diagnosed or repaired. the contact received notification of nhtsa campaign number: 15v793000 (fuel system, gasoline). however, the part to do the recall repair was unavailable. the contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. the manufacturer was not aware of the issue. the failure mileage was approximately 52,000. vin tool confirms parts not available. updated 04/20/16*lj the consumer stated there was a problem with the transmission and the steering. also, the vehicle would suddenly stall, while driving. updated 05/11/16.*jb
Tl* the contact owns a 2011 ford fusion. the contact received notification of a recall for the fuel system; however, the part to do the repair was unavailable. the contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. the manufacturer was not made aware of the failure. the nhtsa campaign number was unknown. the failure mileage was approximately 60,000. parts distribution disconnect. updated 04/29/16*lj updated 05/04/16*jb
2010 ford fusion. consumer writes in regards to fuel system safety recall. *ld the consumer stated the vehicle was not included in the recall due to it being 3 years outside of the warranty. *js
Tl* the contact owns a 2010 ford fusion. the contact stated that when the ignition was turned to the on position, the check engine warning indicator and the fuel inlet warning indicator illuminated continuously. the vehicle was taken to a dealer where it was diagnosed that the fuel inlet filler neck was leaking and needed to be replaced. the vehicle was not repaired. the manufacturer was made aware of the failure and stated that the vin was included in nhtsa campaign number: 15v793000 (fuel system, gasoline). the part to do the recall repair was unavailable. the contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. the failure mileage was approximately 50,000. updated 04/29/16*lj
Fuel tank started leaking fuel when the tank is filled above 1/2 on the passenger side. ford repair shop found a tank defect on the bend of the upper tank flange, stress fracture along the flange that is not normal wear and tear but in my and the repair shop's opinion is a defective tank. i am filing a complaint with ford as in my over 40 years of owning many vehicles of several brands, never had a tank leak - one vehicle i have has 340k miles with no leaks. i see from research on the internet that this problem is not isolated to just me. ford - improve your quality before i buy another vehicle from you! this is an extremely dangerous condition.....updated 10/27/15*bf