Problems with 2006 Volkswagen Jetta ENGINE AND ENGINE COOLING

In the last few weeks my husband and i have noticed a chemical smell similar to wet paint occasionally emitting from the a/c vents. in the last two days, it has become constant and i have refrained from using the a/c for fear that it is something harmful. we have looked the car over, ran the a/c and blower while out of the car and checked everything we can think of with no solution. the dealership suggested we spray lysol in the air intake and see if that helps, but i do not want to mask the odor especially if it something with which we should be concerned. *nm

While driving my new 2006 jetta tdi motor vehicle with a total mileage on the odometer reading of approximately 385 miles, on june 12, 2006, on i-84 in waterbury, ct. the motor vehicle stalled while traveling in the left hand lane of the highway. at the time of the stall, the vehicle transmission was operating in the drive mode, in 5th gear with rpms at approximately 1300 rpm. during the stall the vehicle exhibited intermittent power, while the instrument panel exhibiting a flashing numeral 3, on the gear indicator. i maneuvered the vehicle to the breakdown lane with much difficulty as the engine stalled out completely. this maneuver caused a major interruption to the flow of traffic on the highway and a serious safety risk to me and other motorists on the highway. after pulling over the breakdown lane, i was able to restart the vehicle and proceed to my destination, during which time the vehicle operated normally. on june 15, 2006, driving with approx. 484 miles, while on rt. 8 southbound in waterbury, ct. the subject motor vehicle stalled once again while driving in the left hand lane. i once again was forced to make another emergency crossing of a major connecticut highway in a stalled vehicle. *nm

On 2/1/06 i leased a new 2006 jetta only to have the engine not start on 2/27/06. i was stuck in a gas station parking lot with a dead cell phone awaiting a tow truck for 1.5 hrs. the car was brought to the dealership and they had no idea what was wrong with it. later that day they told me possibly a fuel pump but weren't sure and that i should arrange for a rent-a-car. they had the car for 3 days and when i picked it up they stated it was a program that needed to be updated and everything is fine. it is now a week and a half later and the ignition key wouldn't turn in the ignition. i continued to switch between my alarm key and mechanic key until it finally turned and started. once on the road the car died in mid drive. the engine completely turned off while doing about 25mpg. thank god there was no one around me, the car came to a stop and restarted immediately and driven back to work. leaving work the car didn't turn over at all. you could hear the cranking of the engine but was not turning over, the same problem as before. the car is now at the dealership again, no loaner car was given to me and there was several complaints already underway. another problem is the cars engines sound. when the car is initially started in the morning it is a hard loud rough sound that gives after a minute or so. *jb

2006 volkswagen jetta, engine makes a very loud rattling noise for the first minute everytime the car is cold and at first startup in the morning...every single day , after reporting the problem to my dealer i was told that this noise is on all 2006 jetta's and the manufacturer is working on solving the problem, i first reported the problem last may 2005 when i first bought the car and i have since made 2 official complaints directly with the manufacturer and with the dealer. i have now warned them a third time and will wait the official 30 days before escalating it to arbitration. *nm