On my way home on saturday night, about 2 to 3 streets from my house, my dash started to say low fuel. i continued to drive home because i was so close. i get home and jumped out of the vehicle to listen to my car and everything sounded good. i shut the car off. on monday morning, i walked out and noticed all the oil in the car had leaked out of the car onto my driveway. i immediately called toyota and they said they would send a tow truck. the tow truck driver arrived and checked the oil with the dip stick. since there was no oil in the vehicle, we did not start the engine. he towed the car to toyota (where i have all my work done including inspections-which the last one was done 3 weeks prior to this incident). the toyota mechanics looked at the vehicle. they called me and said a hose under the engine had cracked causing the oil to leak out. they had to order the part and it would fixed and ready by tuesday. the part didn't come in as expected and the car was not fixed until wednesday. i left work on my break to pick up the vehicle wednesday night when they called and said it was ready. i picked up the vehicle from toyota and drove back to work. on the way, i noticed a noise coming from the engine but assumed it was ok since it was just fixed. after my shift (thursday morning), i came out and started the car. immediately after starting the vehicle, a loud banging noise came from the engine. i called toyota and had them tow the vehicle back to toyota. they looked at the car and called me and stated the engine had blown and that it would cost $7000 to replace. they said i could keep the vehicle there until i decide what to do.
On the highway at 75 miles/hour (with my 3 small children in the backseat), loss of engine oil pressure. diagnosed as the engine oil cooler pipe, oil was everywhere without any in the engine. this is a known issue on many engines which was covered by toyota for a limited time/mileage with a limited extended warranty under a "customer support program (ze2)." we were never notified of this potential issue, as we would have elected to fix this prior to an oil blowout, to prevent a potential accident with loss of the engine while driving, particularly with our children in the vehicle.
The engine is emitting smoke, creates rattling sound. at start timing chain sounds scared kids. while driving you can hear knocking sound and if something can break while driving.
Vvt-i oil line failure causing complete loss of engine oil while driving at speed on a highway. car had to be towed and repaired due to lack of quality parts used in the manufacturing process. toyota identified this problem internally yet failed to take appropriate measure to identify all models equipped with substandard oil lines and, likewise, did not attempt in earnest to notify owners of affected models. the result of toyota's lack of appropriate effort in notifying owners resulted in oil line parts failures occurring outside of an extended coverage period instituted by toyota. because toyota did not act in good faith, owners were not notified and were subsequently put at risk of oil line parts failures resulting in engine damage or even engine failure. many of the affected models are still in operation and the drivers of these vehicles will have no idea until the part fails due to toyota's lack of appropriate action. toyota offers no support for this defect outside of a warranty enhancement or limited service campaign which owners were not sufficiently made aware of.
The car was traveling approx. 65 mph on the freeway when suddenly i noticed smoke coming up from under the hood. i immediately pulled off the freeway and in the process noticed the engine sounding different and performance level quickly dropping. i then noticed the oil light come on, so i continued to find the first safe spot available to pull over. i then called aaa and they had to tow the vehicle because the car had evidently drained all of its oil, leaving a puddle. the car was then towed to neighborhood car care in mission viejo. it was noticed at the shop that the engine and compartment were covered in oil. i was told the engine oil cooler line had failed and would need to be replaced with an upgraded part. i was also informed that having the engine coated in oil is a fire hazard, and he told me i was lucky my engine didn't catch fire while on the freeway. he told me after the repair, that i would need to get the engine and compartment cleaned to avoid a fire. out of concern of the potentially dangerous situation i was in, i contacted toyota. they were aware of the probable failure of the part, and said there was a warranty, but they don't inform customers unless they have a failure within the warranty period. had i been informed of this potential danger, i would have had it repaired immediately, before putting myself and family at risk.
Oil cooler pipe malfunction. while driving, the oil cooler pipe started to leak from a hole in the rubber section between the metal clamps. all the engine oil came out within a few minutes while driving on the highway. toyota had a recall in 2011 for this equipment, but no longer allows repair or replacement under recall.
I recently learned it is a "known" issue by toyota that the oil cooler line could rupture. this happened to me as i was driving on a very busy 3-lane highway. my only indication was when the oil pressure light came on, indicating an urgent need for me to pull over. luckily i was already in the right lane getting ready to get off at the next exit, however only 5 minutes earlier i was traveling at a high rate of speed, keeping up with the 3 lanes of traffic. i feel this issue is very unsafe because i barely had enough time to exit the road quickly and since this has the possibility to cease the engine, i feel it could have caused an accident. when my suv was checked my the mechanic he informed me that i had very little oil left in my engine. i contacted toyota who stated they did not see how this was a safety concern. i disagree.
Sudden loss of oil while driving causing me to pull over immediately secondary to loud engine noise, decreased power, and fear of causing more engine damage. local mechanic discovered that the engine oil cooling tube burst and dumped all the oil. serious safety issue when you are forced to pull over to the shoulder on a busy road and left stranded as well as the fire risk when all the oil now covers the engine/underbody/back of vehicle.
The car blew the engine oil cooler pipe leaking profusely i drove it at night came home and there was a 12 x 12 oil leak in my garage. i pulled it out of the garage with the motor running and there was another 12 x 12 oil spill on my drive way. i have a line all the way down my street of the oil spewing out of the engine . i had to get the car towed the following day to toyota who knew about the part and offered an extended 10 year warranty to fix this problem. there was only 2 quarts of oil left in the crank case. no low oil light came on. i would have blown my motor for sure if i was on the highway. there is a video from toyota about the engine oil cooler pipe leaking and that they changed the part from rubber hoses to metal. why was there not a recall on this part. it is not a matter of if it will fail but when. this could have caused a serious situation!
Driving on a rural 2 lane road the car started knocking and the light for the vsc came on. it said to bring to the dealer. got home and checked the oil and there was not one drop on the dip stick. (my oil was changed at the dealer two weeks prior). the oil was however sprayed under the entire undercarriage. the part that is the problem is the oil cooler line.
Purchased this 2008 toyota highlander hybrid new from greentree toyota in danbury ct. we selected the hybrid version to save on gas. little did we know our savings in gas would be sucked up in oil consumption. i need to carry a case of oil in the car at all times. asked toyota service in danbury ct to investigate and they conducted the same oil test others speak about. although they say our highlander passed the test i end up adding about 2 quarts of oil between every oil change. this car was serviced in exact compliance with the recommended service schedule. the toyota service department in danbury ct just says that it is normal for a car with 135,000 miles on it to burn oil. this was a huge investment. i would expect at least 200k miles on a car before experiencing this sort of problem. very disappointing. i would have expected toyota to stand behind their product. instead we get a well orchestrated don't admit any wrongdoing response. toyota should be held accountable for producing a substandard product.
The primary issue of concern is regarding the vehicles valve springs. as a result of the valve spring which was in place, the vehicle in which i drove, stalled multiple times while in motion on a highway, before i was able to get it checked. in order to rectify this it cost over $2,000.00 in repairs. this issue is of grave concern, as a faulty valve spring, if it were to happen on a highway, could result in the death of a driver, passengers, and other vehicles. this issue is similar to the 2010 valve spring issue which affected lexus vehicles. in that 2010 issue, toyota admitted fault and recalled issues for 2006 to 2008 lexus models. given that the issue happened to other brands owned by toyota the dot should see whether the issue is more widespread, and whether my vehicle falls under this issue as well. *js
Driving down roadway when a loud noise was heard in the engine, followed by check oil light to illuminate shortly after. drove to nearest automotive repair site for service fearing more damage to engine by driving farther. mechanic discovered oil line (previously repaired under recall) had burst and emptied all oil onto roadway. previous repair, done under specs of recall, didn't hold up and required another repair. toyota dealership called due to recall being performed there prior. because it was completed to specs, no further assistance was offered. repair completed with metal (not rubber) tubing and paid for out of pocket by driver. fire risk noted since oil sprayed underneath car, onto back of car and onto roadway.
Tl* the contact owns a 2008 toyota highlander. the contact stated that the air condition tube failed while driving. the contact inspected the vehicle and discovered that the air condition tube was exposed to the motor ventilator causing the tube to overheat and explode, spilling the coolant. the vehicle was not repaired. the manufacturer was not notified of the failure. the vin was not available. the approximate failure mileage was 113,000.
Tl* the contact owns a 2008 toyota highlander. while driving 50 mph, the contact smelled burning oil. the contact pulled over and found a leak in the motor oil cooling hose. the vehicle was towed to a dealer to be repaired. in addition, the mechanic found an issue with the cam shaft of the vehicle. the manufacturer was made aware of the issue. the failure mileage was 126,000.
Engine oil cooling (rubber) hose burst while driving and dumped all of my oil ... toyota has since repaired this part with a series of metal pipes, which suggests to me that they realize that this is a defect but it is not acknowledged as a recall
I recently noticed a rattling sound out of the engine area that occurs intermittently. it typically occurs after the vehicle sits for a couple hours after it has been driven up to operating temperature. the sound happens for less than 2 seconds. the toyota dealer in our area diagnosed the issue as a failure of the intake cam gear per toyota technical service bulletin 0094-09. the service advisor stated that if the issue is left unaddressed, it could lead to complete engine failure. he also stated that the updated cam gear made by toyota does not fit the existing camshaft. this means that all 4 cam gears and two camshafts would have to be replaced which dramatically increases the labor and parts costs. i was given the following quote for the repair: part's $3748.00 labor $2137.00 tax $348.00 total $6233.00 i took the vehicle to another toyota to confirm the diagnosis and they confirmed the issue and quoted me at a similar price to do the repair. message boards all across the internet describe a similar phenomenon. after discussing the matter with toyota corporate, they agreed to cover 50% of the parts cost, but i believe this to be unfair because their updated part intrinsically and dramatically increases the labor and parts costs. even though only one cam gear failed, the replacement of all 4 cam gears is now necessary.
According to the following website, there is a known issue with a cheap part on the toyota v6 engines. there was even a recall for the part, however, i"m told my car wasn't on the recal list. https://sites.google.com/site/toyotav6oillinescandal/ the issue at hand is the car has been to the dealer for all maintenance, so its not a neglect issue. the rear bank vvt-i oil line used in prior to 2008 (mine has this issue as well) is metal with a rubber host connecting the two. the hose ruptures, dumps all of the oil, which squirts onto the passenger wheel, in the brakes, etc. it can not only cause a fire in the engine bay (which it did not in this case), but it could also lead to an inability to steer or brake (neither were the case here). lastly, 6 quarts of oil drained out in less than 60 seconds, and the engine could have seized. this is a seriour issue for a $35.00 part.
Tl* the contact owns a 2008 toyota highlander. while attempting to accelerate, the vehicle hesitated and the check engine light illuminated on the instrument panel. the vehicle was taken to the dealer. the technician diagnosed that the fuel pump needed to be replaced. the technician stated that the fuel pump failing was a known issue. the vehicle was then put through a stress test and the service department kept and drove the vehicle. the service manager stated that the failure was not the fuel pump and that there was an issue within the system once the vehicle warmed up that caused the vehicle to lose power. the vehicle was not repaired. the failure mileage was 90,000.
I purchased a qualified pre-owned 2008 toyota highlander sport from rice toyota in greensboro, nc in february of 2013. since that time, i have properly serviced the vehicle and retained all service records. on or about march 31, 2015, while i was driving home from work on i-40 (65 mph interstate highway), the engine in my highlander suddenly stalled and the check engine light came on. i coasted into a rest area (luckily) and was towed to a service station in greensboro. a complete diagnostic was performed and it was determined that the engine failure was due to a faulty engine valve spring. every mechanic i have spoken with have indicated that a valve spring should not break on a 2008 toyota with around 100k miles. i searched online and found that toyota has recalled hundreds of thousands of certain lexus models, including models from 2008 with the same 3.5 liter v6 engine as is in my highlander, for faulty valve springs that result in sudden engine stalling. rice toyota has refused to provide any assistance, as has toyota corporation. further, toyota corporation has refused to provide me with any information regarding the manufacturer of the valve spring in my vehicle and/or any indication if the same valve spring was in the recalled lexus modes. i have seen class action law suits filed against toyota for concealing issues with valve springs. this defect can be very dangerous as the vehicle stalls suddenly and without warning. i need assistance to motivate toyota corporation and rice toyota to correct a clear design and/or manufacturing defect that caused a potentially dangerous engine stall in the middle of a major interstate highway. *tr
Engine oil leaked almost empty. when i picked up kid from school parking on the driveway on that rainy day, saw a leak line on the wet ground. next saturday i filled a qt oil to the level and drove to repair shop. the technician said almost all 5.5 qt oil was leaked out. turned out it was timing chain covers silicon sealer broken. i am the person always check around my car before going out, if not checking, things could be very bad. *tr
The oil cooler hose on my 2008 highlander suddenly malfunctioned, causing most of my car's oil to spill out on to the driveway. apparently, this particular rubber hose has been the subject of recalls and equipment upgrades to a metal pipe in other toyota models, but not the highlander. this is a safety issue that toyota is neglecting to acknowledge in its highlanders. i called my local toyota dealership to report the problem, and ask what toyota is doing to fix it, and they denied there was any kind of problem with the oil cooler hoses. a simple google search implies otherwise. *tr
We were starting off to go on vacation when warning lights came on the dashboard and information panel with hybrid system warnings and brake warnings then the car completely stopped in the middle of the road and steering was lost. we were able to get off to the side enough to prevent causing an accident however we were on a busy street. had it towed to the local toyota dealer and the diagnosis was a failed coil. they replaced all 3 coils saying that it would be prudent as the engine was already apart (i agree). they also said that this is a relatively common occurrence with some of the highlander hybrids. i have the part and it looks like the top of the coil became over heated and blew out the top plastic compound. i consider myself very lucky that this did not happen while on a highway on a rainy day where the vehicle abruptly stopping would certainly have caused me to be in an accident. this is certainly a flaw that toyota should address for safety reasons and it makes me hesitant to want to purchase another toyota product again. *tr
When you start up car there is a engine grinding noise for a few seconds. this has been reported by many people on the internet, just google 2008 toyota highlander start up engine noise and you will get a better look at what it sounds like. this could lead to severe engine damage . it is a defect in the engine.
I normally ride a vanpool, but due to flash flood warnings today i decided to drive my car into the office. my husband called me at work to tell me he noticed a big oil spot on the garage after i left for work. he told me to pull over and not drive my highlander if it started clacking or smoking on my way home. my husband just changed the oil in my car a few days prior. before i could make it home the car was smoking, knocking, and shifting very loudly. my husband said i was lucky this didn't lock up the engine. he discovered oil splatters all over the tire and near the engine. we had no issues at all prior to today. we are going to try replacing the oil line as denoted in other peoples comments. their experiences with this issue mirror my experience. i'm disappointed to hear toyota issued a service bulletin about this and not a safety recall. this could have been a huge safety issue as i'm hauling kids to/from daycare during rush hour traffic not to mention locking up the engine. this came out of the middle of nowhere. *tr
Toyota's t-sb-0201-1 should trigger a recall!! my wife was driving her '08 highlander, with 2 co-worker passengers, to a funeral. on 95n in danvers, ma, a motor biker pulled alongside & flagged my wife to pull over asap as there was smoke coming from the engine compartment and under the car. after stopping the car & waiting for the smoke to dissipate,he checked & found there was no longer any oil in the engine, the oil had emptied from the engine the last few miles while on the highway. i arrived later that morning to investigate, to discover that the oil was below the dipstick. the bottom of the engine & entire underside of the vehicle, including the exhaust system, spare tire, wheel wells, right wheels & tires & rear liftgate were coated in engine oil. the smoke apparently was from oil splashing onto the hot exhaust system, & vaporizing due to the high temp, creating a potential fire hazard. we had the car towed to the nearest toyota dealership. they determined that an oil cooler line external to the engine - part of a towing option package the car has - had ruptured! the engine's oil had been pumped out by the oil pump. we have since discovered that toyota had issued a technical service bulletin - t-sb-0201-11 - in december 2011 which addressed "oil seepage" from this exact oil line. now we are $480 poorer, & we could have experienced a $10 k engine failure due to seizing, & possible injury or loss of life due to this. this tsb was never performed on our car as we had never seen spotting in our driveway from this leak. the new part installed was redesigned as solid metal tubing to fix the original rubber hose with clamps. instead of recalling all of the affected vehicles to replace this potential life taker, toyota simply swept it under the rug and only replaced them when someone saw a leak and only when they still were below their 36,000 mileage warranty. crazy! *tr
Driving in parking lot at approximately 5mph when smelled burning oil. parked car and noticed smoke from under the hood. turned off car and checked under the hood and noticed oil over engine. searched online and saw issue with oil-cooler line "toyota: on some vehicles, the engine oil cooler pipes may exhibit an oil seepage. information has been provided regarding this issue". this did turn out to be the issue. fortunately this even occurred when we were in a parking lot and not driving down the highway with kids in the back. this is a significant issue that could result in a fire and/or engine damage. the dealer stated they were aware of this service notice but no official recall had occurred. this has the potential to be a significant issue to both the cars and passengers and i hope that a recall would occur. *tr
The oil line has degraded, causing total loss of engine oil and possible engine damage. *tr
High pressure oil cooler line failure of rubber hose section dumped 5 qts of engine oil soaking undercarriage and spraying onto nearby hot exhaust pipe and right rear tire. no indication of loss of oil pressure on vehicle monitoring system. noticed a faint smell of burnt oil when vehicle was parked. returned later to start vehicle and heard audible engine noise and turned of engine to investigate under hood, a noticeable puddle of oil had accumulated under car. vehicle towed for diagnoses and repair. *tr
Tl* the contact owns a 2008 toyota highlander. the contact stated that while driving 10 mph, she began to her a knocking noise in the engine. the contact parked the vehicle and had it towed to a certified mechanic which stated that the engine cooler hose had a hole and cause the engine oil to leak out of the vehicle and needed to be replaced. the vehicle was not repaired. the manufacturer was notified of the failure. the failure mileage was 100,000.
Oil pressure warning light went on almost immediately pulled over found no oil on dipstick had rapid oil leak, dealer replaced oil cooler hose with oil cooler pipe. *tr
Tl* the contact owns a 2008 toyota highlander. the contact was driving 55 mph when the vehicle began to emit a burning oil smell. the check engine lamp illuminated so the contact added oil to the vehicle. the contact stated that the burning oil smell still lingered and the check engine warning lamp illuminated again. in addition, a hose from the engine failed and spilled motor oil on the exterior of the vehicle. the vehicle was towed to the dealer for inspection where the contact was informed that the oil cooler line had exploded. the vehicle was not repaired. the manufacturer was not made aware of the incident. the approximate failure mileage was 200,000.
The vvt-i oil cooler hose burst resulting in a major engine oil spill in a residential driveway. the toyota dealership and toyota corporate headquarters refuse to assume responsibility for the defective part because the vehicle is outside the warranty period and because they claim there is no recall for this part on the highlander. this same vvt-i oil cooler hose has been recalled on 1.6 million us rav4's, camry's and other toyota models. not only could a total loss of engine oil cause catastrophic engine failure, this issue can also be considered a safety concern. if engine oil were to have made contact with hot engine parts or hot exhaust piping, then a fire may have occurred which could have resulted in serious vehicular damage and loss of life. *tr
2008 toyota highlander was taken to toyota dealer in november 2011 after receiving notice to have defective oil cooler hose checked. in september 2013 replacement oil cooler hose failed while on highway traveling at seventy miles per hour. oil was observed covering bottom of vehicle and film of oil on back of vehicle. the oil gauge indicated no oil in engine. i believe this resulted in a safety hazard from both inhaling fumes and potential fire hazard. vehicle was towed to toyota dealer and oil cooler hose replaced for second time in less than two years. *tr
Low oil notice came on. drive 1/4 mile to oil change facility. was told almost no oil on dipstick. oil refilled and drove appro 5 miles to dealership- star toyota , league city, tx. have researched and noted tsb issued on 3/11/2011- nhtsa reference # 10033553 with this exact repair problem inclusive of my vehicles exact failure was not notified by star toyota dealership of this defect while under warranty. vehicle within 5-6 months of basic warranty; 5 year of 60,000 miles. *tr
Engine began revving upon acceleration from a stop light. engine warning light came on indicating low oil pressure. pulled into auto repair shop who found dipstick was dry. poured oil into engine only to see it leaking out from below passenger side. car was then towed to local toyota dealer. dealer replaced oil cooler hose 15767-31010 which had failed with 15767-31020 (all metal assembly). replaced oil and restarted engine. engine is making tapping sound and dealer recommends full replacement. depending on option, cost is between $7500 for a used toyota engine to $8300 for jarco engine (which i believe is rebuilt). this occurred in south carolina while we were vacationing from maryland. thankfully, we were not on the highway when this occurred. will have to leave vehicle here for repair and fly back to drive it home later. btw, the single pipe oil hose was replaced in may 2010 under the ssc 90k recall at 33k miles. that is not the part that failed. this is the dual manifold rubber hose that toyota has now replaced with an all metallic assembly. as far as i know, this part was never recalled, but there is a tsb 02011-11 available. *tr
Tl* the contact owns a 2008 toyota highlander. the contact stated that after parking the vehicle, he noticed a large amount of oil in the driveway. the contact checked the oil level and it showed that there was no oil in the vehicle. he then added oil and found a steady stream leak from a rubber hose. the contact purchased an after market metal hose and replaced the defective hose. he then drained the oil and found that there were metal shavings in the oil, which he assumed came from the bearings. the manufacturer was notified of the failure. the vehicle had not been repaired. the failure and current mileage was 64,000.
I just became award of this: "t-sb-0201-11 from toyota that states "some vehicles equipped with 2gr-fe/fxe towing package engines may exhibit an oil seep from the engine oil cooler pipes." *tr this tsb affects my model year and i believe it also affects toyota and lexus vehicles going back to at least 2008-present. to me this is a major safety issue and this should be handled as a recall instead of a tsb due to the severity of the issue if/when the pipe breaks. the rupture of the oil line will cause the engine to seize thus increasing the risk of a crash with resulting injury and possible death. and there is the hazard to other motorists with oil on the roadway. compared to the recall for floor mats and accelerator issues, this issue, which can drain the oil from your engine very quickly, destroy the engine, and very possibly cause an accident should be of major concern to all. the toyota advice to check for slow oil drips around the rubber hose is unrealistic for the owner due to the location. and the schedule routine service interval is much too long to wait for such an significant inspection. nhtsa needs to compel toyota to replace all of the defective rubber engine oil cooler pipes with the newer metal ones that the tsb addresses. this directive should apply to all toyotas including already made replacements for which the owners have paid for.
Tl* the contact owns a 2008 toyota highlander. the contact stated that while driving 10 mph, the engine stalled without warning. the vehicle was restarted and taken to the dealer for inspection. the dealer was unable to diagnose the cause of the failure. the vehicle was not repaired. the manufacturer was notified of the failure. the failure mileage was 100,000.
My wife started the car in the morning to drop the kid to school which in within 2 miles of our home. it was cold day of winter. she heard a loud noise from the front part of hood when she drove about 1/2 a mile and was worried with the kids what is that noise. any how after that the car had start making squishing noise from the front of the hood. we took to toyota and they said water pump needs to be replaced. i have also read some other people reviews online regarding the water pump of toyota vehicles. my wife called the toyota motor co for warranty and they said, even that is not a part of power train and it is not covered under warranty. so we are ending up paying extra approx $650.00 to toyota for the replacement. *tr
Oil leak from backside of engine. toyota has acknowledge the issue with a service bulletin tsb-0321-08 but did not perform a recall. therefore, you may experience this problem and you may find the issue after your warranty expired. this is a very expensive repair - estimated to be more than $2k. toyota continue to experience quality problems and should honor their products within or outside their warranty when it is clearly related to poor quality. *tr