Problems with 2001 Ford Ranger SUSPENSION

Takata recall. my vehicle was stationary when i got to work i nothing my rear bumper fell off with no given warning and i didn't hear it hit the ground i got home and looked under the frame and noticed the whole frame was rotten away and is not safe to drive

The frame on this truck has rusted to the point where it is unsafe to drive. the rear bumper actually fell of the vehicle while it was being driven. i took off the bed and cut off the rear part of the frame and welded on a new rear section and put on new leaf spring hangers and re installed the bumper a few years ago and re coated the frame with paint but now it has gotten worse to the point where i can no longer drive it as there are actual holes rusted thru. it needs a frame replacement or it just a parts vehicle.

Frame is rotted everywhere for the most part spare tire is about to fail off isn't safe to haul anything in the bed

Frame is rusting away. both rear shock mounts. gas tank holding straps. both chasis rails are rusting away with big chunks of steel falling off. trans cross member rusting away

Frame rusted even thou we paid for undercoating no accident trying to prevent accident without scraping the vehicle can send pictures, but this form does not work

Tl* the contact owns a 2001 ford ranger. the contact stated that the vehicle made a noise by the wheel bearing. the contact took the vehicle to a certified mechanic and was informed that the wheel bearing needed to be replaced. the certified mechanic also stated that the frame and the leaf springs were severely rusted, causing the leaf springs to detach. the vehicle was not taken to the dealer or repaired. the manufacturer was not made aware of the failures. the approximate failure mileage was 182,000.

Bought a used 2001 ford ranger after driving it for a month or so shocks were really bad looked underneath to find two clean cracks through from near back shocks not sure if bad shocks are to blame or weak frame

Serious structural frame rust affecting areas related to suspension (shocks, brackets/shackles of leaf spring) while the rest of the truck, including the body is generally unaffected by any serious rust.

Frame bad.spare tire fall off and back bumper fall off.spare tire fall off when i was parking in a parking space.frame is in very bad conditon.

Severe rust on frame. rear spring hangers broke. spare tire holder rotted and needed to be removed. cracked frame behind front spring hanger of right rear spring. driveline in good condition as was the rest of the body.

I own a 2001 4x4 ford ranger xlt. body, interior perfect condition. always garaged, just over 100k miles won't pass inspection. frame rotted out! ford should replace this frame or buy back the truck. it is useless to me in this condition. i was told that repairs could cost up to $2000 or more. i feel ripped off by ford motor company. this is my last ford.

This is in addition to a previous complaint that i filed earlier today. i own a 2001 ford ranger 4x4 xlt. body and interior all perfect. no rust on body. frame is rusted through in back of area that rear shackles are attached to. shackles themselves have been replaced two years ago. truck will not pass inspection and i am told cost of repairs could be around $2000 or more. the mileage on this truck is just over 100k. i am very disappointed in ford motor company. i've owned many ford vehicles, some a lot older than this truck and never experienced anything like this.

Tl* the contact owns a 2001 ford ranger. while servicing the vehicle, the contact noticed that the frame was corroded and fractured. in addition, the suspension was corroded. the vehicle was unsafe to drive. the vehicle was not diagnosed or repaired. the manufacturer was not notified of the failure. the failure mileage was 58,000.

I bought my ranger 12 months ago. 6 months ago i noticed the bed of the truck was starting to lean to the left. also the spare tire came up missing. i thought it was stlolen but upon inspection it had simply rusted the holder under the truck and fallen off. 3 months ago the truck started making a grinding noise upon braking. the right front a arm had rusted and broken off the frame. a mechanic had to weld a piece of metal to the frame because there was nothing to weld to. then i finally decided to look under the truck and was shocked at what i found. the bed floor was nearly non excistant. rusted almost completely gone. the spring shackle on the right which is attached to frame with a bracket were sticking up against the bed liner, the bracket completely gone. the tube that holds the right shock absorber is completely rusted off, the shock absorber just hanging there. mechanics have told me theres no way to repair because theres no viable metal left to weld to. its simply rusted away. so now im left with over 3 more years of car payments on a ...

Frist, rear spring shackles rusted through had to be replaced, now rear frame where the shock tower hooks up is completely rusted through ( frame is severely rusted to on safe condition )in motion heard a loud rattle pulled over to see what it was .we have pictures but could not download them on this form.