Problems with 1999 Ford F-150 FUEL SYSTEM, GASOLINE

Truck was parked and pulled out of parking spot when the both fuel tanks straps failed and the the tank dropped to the ground. *tr

1999 ford f-150. consumer writes in regards to recall repairs not being completed *tgw the dealer informed the consumer that one of the two straps was completely rotted and just hanging there and not supporting anything. therefore, the gas tank was being held in place by only one strap. the dealer stated they could not make the repairs due to the corrosion, as it had affected the frame where the gas tank attached too. the consumer stated ever since he went to the dealer, there is an odor of gas emitting from the vehicle. *jb

I brought in my 1999 ford f150 to get an inspection and get a recall performed on the straps that hold the gas tank on. the garage had the vehicle for 6 days before they informed me that they in fact could not perform the safety upgrade because the frame of the truck has too much rust. i believe that ford motor company is responsable for not providing adequette protection fro the elements on the frames of this make/model of vehicle. i called the ford motor company and was told that they were only responsable for the gas tank straps and not the frame so they were not requiring their dealership to do the upgrades. when my best friends 1999 toyota tacoma had the same eact problem on his truck the toyota company paid to put a new frame on his truck due to a recall of the frame. the rest of my ford truck is in great condition and has around 120,000 miles on it. i have had no other issues with the truck except for the frame. because of this issue the only real choice i have at this point is to scrap the truck and buy another ...

Tl* the contact owns a 1999 ford f-150. the contact received notification of nhtsa campaign id number: 11v385000 (fuel system, gasoline:storage:tank assembly:mounting) and took the vehicle to the dealer for repairs. during the recall repairs, the fuel tank began leaking abnormally due to corrosion of the fuel tank and straps. the manufacturer was contacted and they advised the contact that they would not replace the tank or the straps. the failure and the current mileages were approximately 208,846. updated 01/18/2012*lj updated 02/29/12

Tl* the contact owns a 1999 ford f150. the contact stated while driving at approximately 20 mph, the fuel tank detached from the vehicle. the vehicle was taken to the dealer who performed a diagnostic. the failure was located at the fuel tank strap frame rail, which was corroded and caused the fuel straps to corrode. the vehicle was not repaired. the failure and the current mileage was 100,000.

Tl* the contact owns a 1999 ford f-150. the contact stated while refueling the vehicle, fuel emitted from the fuel tank. the contact also stated the under carriage was corroded. the vehicle was taken to the dealer for diagnostic testing. the manufacturer was notified of the failure. the vehicle was not repaired and the vin was unknown. the failure and current mileage was 223,000.

Tl* the contact owns a 1999 ford f150. the contact received notification of nhtsa recall number: 11v385000 ( fuel system, gasoline:storage:tank assembly:mounting) and took the vehicle to the dealer for repair. the dealer advised that there was a hole in the fuel tank, which needed to be replaced. the manufacturer was not notified nor was the vehicle repaired. the current and failure mileages were 157,000. the vin was unavailable.

Tl* the contact owns a 1999 ford f-150. the contact stated that the vehicle was taken to an authorized dealer to be repaired under the recall associated with nhtsa campaign id number 11v385000 (fuel system, gasoline:storage:tank assembly:mounting). the contact was informed that the fuel tank also leaking, but that failure was not covered under the recall. the fuel tank was not repaired. the manufacturer was made aware of the failure and offered no assistance. the failure mileage was 123,800. updated 12/14/11

Tl* the contact owns a 1999 ford f-150. the contact received a nhtsa recall campaign number: 11v385000, fuel system, gasoline: storage: tank assembly: mounting. the ford recall campaign number was 11s21. he took his vehicle to the dealer to be repaired but there was a bolt that was holding the straps which was covered with rust and corroded. the dealer stated they would not repair the recall since the bolt was covered with rust. the contact was informed that the bolt repair would cost the contact $300 or they will not return his vehicle to him. the contact does not want the bolt repaired if it was not a part of the recall repair. the manufacturer was not notified of the failure. the failure mileage was 64,000.

Tl* the contact owns a 1999 ford f150. the contact stated that there was rust and corrosion on the fuel tank. neither the dealer nor the manufacturer was notified of the failure. the vehicle was not repaired. the failure mileage was 117,000.

Tl* the contact owns a 1999 ford f-150. the contact stated that while driving 10 mph, the vehicle exhibited a strong fuel odor. the vehicle was taken to a local mechanic who performed a diagnostic that located the failure as the fuel tank being corroded and causing the fuel tank to leak. the manufacturer was contacted and a complaint was filed. in addition, the manufacturer advised that they could assist by replacing the fuel tank straps only and that the vehicle was not included in nhtsa campaign id number: 11v385000 (fuel system, gasoline:storage:tank assembly:mounting). the vehicle was not repaired. the failure and the current mileage was 115,000.

Tl* the contact owns a 1999 ford f-150. the contact stated that there was a fuel leak in the vehicle. the vehicle was taken to the dealer for repairs under nhtsa campaign id number: 11v385000 (fuel system: gasoline: storage: tank: mounting) but the contact was advised that the fuel leak the contact was experiencing would not be repaired under the recall. the contact stated that the leak was caused by rust and fractured straps on the fuel tank. the contact believed the failure was a manufacturing defect and should have been added to the original recall. the failure mileage was 185,000.

Tl* the contact owns a 1999 ford f-150. while the vehicle was parked the contact inspected the vehicle and noticed the fuel tank was corroded. the vehicle was included in the nhtsa recall id number: 11v385000 (fuel system, gasoline:storage:tank assembly:mounting). the manufacturer was made aware of the failure and stated the fuel tank would not be replaced under the recall. the vehicle was not repaired. the approximate failure mileage was 69,000.

Gas leaking from back end of gas tank. gas tank rusted through on back of tank were a plastic shield was afixed by ford. removed plastic shield and entire end of gas tank rusted and leaking. brushed away loose rust and multiple holes appeared and gas poured out. the plastic shield has a space between it and the tank which collects dirt/snow and road salt causing the gas tank to fail and leak. the rest of the gas tank is sound except for the straps that hold it in place. ford has issued a recall for the straps. ford should consider the entire gas tank for recall because of this plastic cover that cause the gas tank to fail and leak. a very serious danger of fire. *tr

Tl* the contact owns a 1999 ford f-150. the contact received a recall notice in the mail for repairs under the nhtsa campaign id number: 11v385000 (fuel system, gasoline:storage:tank assembly:mounting). the contact took the vehicle in to be repaired and during a diagnostic test was advised that the mounting was covered with rust. the dealer and manufacturer denied the recall stating that the contact would have to purchase a new mount before the recall could be performed on the vehicle. the vehicle was not repaired. the failure and current mileage was 160,000.