Problems with 1999 Ford E-150 STEERING

The 3 mounting bolts attaching the steering box to the frame broke/sheared off as the vehicle was being parked in the driveway. 1999 ford e150 van. a loud popping noise or bang was heard and total loss of steering was the result of the steering box dangling from the frame. the vehicle was being repositioned on a flat driveway, no incline at all. no injuries resulted , but if the failure had occurred during operation, steering would have been inoperable leading to an accident which easily could have led to serious injury to the driver, passengers, and other vehicles and their occupants. *tr

Major shaking in the front end of the vehicle and steering control greatly reduced. this problem has been on going, and the dealer keeps telling me it is normal. if this is normal, than these vehicles need to be removed from the highways before death occurs. *jb

Tie rod broke loose almost make very serious accident. tie rod also broke two years ago. *la

Vehicle veered off the road and into a tree. *ph the air bags did not deploy during the accident. nhtsa did some testing but could not pin point the problem. a recall was initiated which the consumer received august 24, 2003, 30 days prior to the accident. since the vehicle was to be out of service for approximately two weeks the consumer was in the process of rearranging his schedule to comply when the failure occurred. five days after the consumer purchased the vehicle the brake unit failed. the manufacturer replaced the unit after some installer/manufacturer disagreements. the emergency brake never worked properly. *nm

Ltr fm denis bittenbender (pa) writer is a quadriplegic use of electronic equipment to operate vehicle involved in accident electronic equipment failed causing accident request nhtsa test equipment defect, reply to the allentown ofc dot 2004-4251. *la the vehicle had run off the highway and ran into a tree in which the vehicle veered at a 30 degree angle to the right an did not respond to any actions the consumer tried to perform. on another occasion, the brake unit failed and the manufacturer replaced the unit. the emergency brake never worked properly and the air bags did not deploy. *sc it was also possible the van had a steering problem. *jb

The steering linkage fell off my 1999 ford e150 van nearly causing a severe accident. my wife was driving the van. my four children with her. she lost control of the van after the linkage fell off. she barely had time to stop before going through a fence. i am an engineer. it would seem that steering linkage would be comprised of components with an insignificant risk of failure. we do not trust the van anymore. it is hard to imagine what might have happened to my family if they were on the freeway when the linkage fell off.

At 35mph consumer would try to make a turn but vehicle will delay the turn. cause unknown. dealer notified.*ak

The brake pedal was depressed but the vehicle did not slow down. the driver applied the pedal harder but the brakes did not engage totally and the vehicle experienced extended stopping distance. the vehicle was taken to the dealer who determined that the brake rotors were pitted and rusted and the brake pads were worn. the power steering gear box leaked. *nlm *nlm

Steering wheel will crunch when going around corners, dealer replaced steering box. after 200 miles, one bolt of steering box shreaded off. *ak *slc

Tie rod came off while driving and crashed to a stop. *slc

E-150 van steering column "clunks" during turns. identified problem when van was new. told that it wan't dangerous. sound is increasing with age.

Steering wheel will not turn when brakes applied. *ak

Could hear a noise when turning. contacted dealer, and they replaced steering pump assembly. noise still present after repairs and has not yet been fixed. *ak *ml