Fuel back flows out the gas tank on the ground no matter the fuel level. fuel will dump onto the ground at varying degrees. multiple reports by the forums. i will be submitting this link so others can post to prove this is not a one time thing
Tl* the contact owns a 2005 chevrolet tahoe. while adding fuel to the fuel tank, the fuel pump shut off and the fuel spilled out. the contact stated that the failure occurred each time the vehicle was fueled. the vehicle was not taken to a dealer or an independent mechanic for diagnostic testing. the manufacturer was not notified of the failure. the approximate failure mileage was 122,836.
Tl* the contact owns a 2005 chevrolet tahoe. when the fuel tank was filled up, the tank exploded and splashed fuel all over the contact. the contact's vehicle also vibrated while driving at any speed and the abs warning indicator illuminated. the vehicle was taken to an independent mechanic (dns auto repair, sebastian, fl) where several failure codes were diagnosed. the vehicle was taken to another independent mechanic (tire kingdom, sebastian, florida) where it was diagnosed that the tires needed to be replaced. the tires were replaced. the manufacturer was not made aware of the failures. the failure mileage was approximately 123,250.
Very bad fuel leak on top of gas tank gas pouring all over the tank
The fuel line rusted through where it exits the gas tank causing fuel to leak all over the top of the gas tank.
On february 7th the driver side airbag spontaneously deployed as my family and i were driving home from the store. we contacted gm to find out if there were any recalls on our vehicle. we were instructed there were not and we should contact gm customer service. on february 11th they had us take our vehicle to a gm dealership where they conducted and investigation to determine why. gm returned our vehicle to us on march 3rd stating the airbag deployment was caused by shorted wires in the wiring harness. since our vehicle was returned to us we have had several more issues that were not present prior to the airbag deployment. the driver seat is stuck in one position, the rear windows will not work, the rear locks will not work, the fuel system is leaking gas, and the battery is dead, even having to be jump started when it was returned to us. general motors refuses to do anything to correct the problems, stating these problems are not a manufacturer defect. however, when the airbag blew, while we were driving down the road, there was significant smoke inside the dash, we believe the airbag burnt/shorted the wires after it deployed. gm claim number [xxx]. information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6). *tr
tighten fuel cap warning started coming on and now having issues with refueling. gas pump shuts off constantly while trying to refuel and gas spews out all over, takes forever just to manage to pump 10.00 worth of gas in it, very frustrating to say the least along with money wasted from fuel shooting out while trying to pump gas. seems like gm would have a recall on this issue as from doing research there are many others with this same problem !!!!
Tl* the contact owns a 2005 chevrolet tahoe. the contact smelled fuel inside and outside the vehicle. the vehicle was taken to an independent mechanic who stated that the fuel pump needed to be replaced. the vehicle was repaired. the manufacturer was not notified. the approximate failure mileage was 113,000.
Tl* the contact owns a 2005 chevrolet tahoe. the contact stated that the fuel gauge failed to operate. the contact mentioned that when the vehicle was turned off and restarted; the fuel gauge level would display a different amount. the vehicle was taken to an independent mechanic. the technician diagnosed that the fuel sending unit needed to be repaired. the vehicle had not been repaired. the manufacturer was notified of the failure. the approximate failure mileage was 103,000.
When attempting to crank vehicle, it just turned over acting like it was not firing. will finally crank after several attempts. after having issue looked at by a mechanic, he stated that ignition was sending a false signal to cam. shortly after the odometer started giving a error and cannot get the present mileage any longer. just learned of this site and was trying to see if others were having the same problems. have not yet taken to mechanic on issue with odometer. *tr
Tl* the contact owns a 2005 chevrolet tahoe. the contact stated that the key failed to turn and start the vehicle after numerous attempts. the vehicle was finally able to start, but the failure recurred. in addition, there was a fuel odor coming from the vehicle. the contact discovered a fuel leak near the rear of the vehicle. the vehicle was taken to a private mechanic who diagnosed that the fuel pump and the fuel lines needed to be replaced. the vehicle was repaired. the initial failure was not diagnosed. the contact stated that the vin was not included in nhtsa campaign number: 06e043000 (fuel system, gasoline). the manufacturer was notified of the failure. the approximate failure mileage was 125,000.
Mechanic informed me that my fuel and brake lines need to be replaced due to the fact that they are totally corroded. *tr