We have classified the 2 complaints from 2005 Chevrolet Silverado 3500 about POWER TRAIN into the following categories.
Tl* the contact owns a 2005 chevrolet silverado 3500. the contact stated that the gear position indicator lighting failed to illuminate. the failure was not diagnosed or repaired. the manufacturer was made aware of the failure. the approximate failure mileage was 79,000.
Tl* the contact owns a 2005 chevrolet silverado 3500. the contact stated that oil was leaking from the rear half of transfer case housing. the vehicle was taken to a private mechanic for inspection and the manufacturer was made aware of the failure. the vehicle was repaired. the failure mileage was 78,000 and the current mileage was 78,637.
Tl*the contact owns a 2005 chevrolet silverado 3500. the contact stated that the vehicle has been to the dealer fifteen times for a variety of failures. there were defective fuel injectors and fuel pumps, the r& r intermediate steering shaft was replaced, and there was an occasional transmission leak. the dealer could not duplicate the leak. the contact ordered a spare tire, but it was never received. he consulted the manufacturer, who only informed him that there were no recalls or issues with his vehicle. the contact also spoke with the state attorney general. the current mileage was 22,000 and failure mileage was approximately 500.
I believe my 2005 chevrolet silverado 3500, duramax/allison was equiped with under designed cooling systems; both transmission and engine. on slow mountain type roads i can run my unloaded truck into near overheat conditions. i believe these issues may be common to other '04.5 and '05 lly gm and chevrolet trucks like mine and gm has not provided it's dealer network with solutions to remedy the problem (most of them are simple, that the other 2 majors seem to understand: air flow control throught the cooling stack and cold air to the intake)