Problems with 2009 Chevrolet Silverado 1500 STRUCTURE

The dashboard in my silverado has mysteriously developed cracks around the steering wheel area and the airbag. i am afraid that if something were to happen that it could project plastic pieces causing bodily harm if the airbag were deployed.

I was driving about to get on the highway as i came to on ramp i heard a noise as continued seemed to get louder so i pulled over and had it towed approx 70-80k miles, replaced wheel bearings sides. continuous multiple misfire, driving vehicle starts to shake loss of power... callaps/ frozen lifter(s) with only 110k, tail gate latch have to bungee to keep closed, transmission replaced before recommended factory tansmission/ transfer case change... problems ranged from approx 2013 to present. now dealing with lifter(s)...

Dash cracked above passenger airbag.

Tl* the contact owns a 2009 chevrolet silverado 1500. while driving various speeds, the door opened independently. the vehicle was taken to diamond auto group (768 washington street, auburn ma, 01501) where it was diagnosed that the driver's side exterior door handle fractured and needed to be replaced. the vehicle was not repaired due to the cost of repairs. the manufacturer was notified of the failure; however, the vin was not included in any recalls. the failure mileage was approximately 20,660.

The dashboard is cracking. it has already cracked in three places. one place just above the passenger air bag.

Dashboard has cracked in two places.

The truck was sitting parked in the driveway and my neighbor noticed that the lights and wipers came on (truck was not on, no keys were in it, nobody was in it or near it!). smoke then began to billow out from under the hood and a fire started. my neighbor was able to disconnect the battery and put out the fire. i had the truck towed to a garage where they told me that the fuse panel caught on fire. they called gm and was told there was no recall for the part. dealing with insurance now.

Tl* the contact owns a 2009 chevrolet silverado 1500. the contact stated that the passenger side dashboard was cracked near the air bag compartment. the cause of the failure was not diagnosed. the vehicle was not repaired. the manufacturer and local dealer (bryan chevrolet located in kenner, la) were notified of the failure, but no assistance was offered. the vin was unknown. the failure mileage was 45,000.

Dash board is cracking on passenger side by airbag in tow places and on driver side by window vent

Dashboard is cracked in two different plaeces

Tl* the contact owns a 2009 chevrolet silverado 1500. the contact stated the undercarriage of the vehicle was corroded. the vehicle was taken to the dealer where it was diagnosed that the spare wheel assembly, bed assembly, and tailgate assembly needed to be replaced. the manufacturer was notified of the failure. the approximate failure mileage was 33,500. the vin was unavailable.

Dash cracks.

Tl* the contact owns a 2009 chevrolet silverado 1500. the contact noticed multiple fractures around the location of the passenger side frontal air bag. the vehicle was not diagnosed nor repaired. the manufacturer was notified of the failure. the failure mileage was 79,000. the vin was unavailable.

Same as many others.crack on dash board left corner connecting to air bag. crack on top of dash board above gauges.

Cracked dashboard near passenger airbag. can present a hazard if passenger airbag deploys and the dashboard fails in a way that can send broken pieces, injuring the passenger more severely during a collision.

The dashboard is cracking in different areas which could lead to a safety issue with the passenger airbag

Tl* the contact owns a 2009 chevrolet silverado 1500. the contact stated that the dashboard was cracked in several different areas, leaving holes and separation in the dashboard. the contact also indicated that a crack developed near the position of the passenger side air bag. the cause of the failure was not diagnosed. the vehicle was not repaired. the manufacturer was notified of the failure. the failure mileage was 87,000.

I currently own a 2009 chevrolet silverado ltz crew cab with approximately 96k miles i have owned this car for about a year now since purchasing a noticed a crack on the driver side dashboard under the instrument cluster and on the passenger side next to the passenger air bag. also the two door handles one being the driver front and the other being passenger front the chrome finish seems to be defective and not staying adhered o the handle and come off in sharp edges making it easy to cut you hand. as the dealership knows this is a defect in the manufacture they used on these trucks the 2 issues on here are not just on 1 vehicle but numerous silverado tahoes and trucks with the same dash and handles. it seems like they pose a safety issue because the handle may cut you and the dash may project sharp pieces if jagged plastic if involved in a collision. myself and many others feel that the general motors knows about the safety issues and as the vehicle manufactures should do the right thing and fix a defective and dangerous product they put out with the form of a recall. i've seen this issue range from trucks between 2008-2012 with 1- 10000000 miles. *tr

Dash board cracked by passenger airbag. *tr

Tl* takata recall. the contact owns a 2009 chevrolet silverado 1500. the contact stated that the dashboard had cracks that progressed from the middle to the front passenger side of the vehicle. the cracks could affect the safety of the air bag components. the vehicle was included in nhtsa campaign number: 16v381000 (air bags), but the contact did not receive a notification. a dealer had not been contacted yet to diagnose and repair the vehicle. the manufacturer was notified years later. the approximate failure mileage was 60,000. vin tool confirms parts not available.

2009 chevrolet silverado with 15000 miles. two cracks on dash one by passenger side airbag, and one right above gauge cluster(speedometer). very common on these trucks. *tr

The dash cracked in several places and the door trims are all falling off.

Tl* the contact owns a 2009 chevrolet silverado 1500. the contact stated that the front passenger side dashboard fractured from heat stress. the dealer and manufacturer were made aware of the failure. the vehicle was not repaired. the failure mileage was 90,000.

Cracked dash around gauge cluster and passenger air bag. potential hazard if air bag deploys.

I noticed that the that the console under the steering column started to crack. nothing happened to cause the issue at all. then about a year later i noticed that the dashboard near the airbag on the passenger side also began to crack. of course at this time the vehicle was out of warranty, and i would have to repair out of pocket if i wanted fixed. there are several other things like the automatic lock actuator malfunctioned. i am really disappointed in this particular year workmanship. for this reason, i have recently purchased another vehicle, and did not consider chevy at all. they need to step up and fix this issue. it obviously is a defect that is a vendor issue. *tr

my 2009 chevrolet silverado was parked for two days. it was running perfectly up until it was parked..after two days of being parked in the rain,the rear tail light suddenly went on by itself. i opened the door to the vehicle to see how this could happen and the "service engine soon" light was on. i put the key into the ignition and it was totally dead. i opened the hood and lifted off the fuse panel cover,because there was a strong smell of burning. then,there was smoke. i immediately disconnected the battery and had the vehicle towed to the nearest dealer. after picking it up today,they charged me $1555 to repair,yet could not provide a logical reason why this happened! they said"corrosion" in the fuse panel. how could a vehicle made in 2009 with 72,000 miles have a problem such as this without a major issue being wrong? i fear for other's safety,as i believe there is a serious issue going on. per my research,there is a technical service bulletin that explains the problem. pit-5090. there is an issue with water being allowed to enter the fuse panel box due to poor design and the poor installation from the factory of a rubber seal. very serious issue! please investigate!!! i have defective parts in my possession and can provide pictures if needed! should be recalled or owners should have their vehicle inspected asap. *tr

Tl* the contact owns a 2009 chevrolet silverado 1500. the contact stated that there were two large fractures located on the top portion of the passenger's side dashboard and a large fracture on the driver's side. the contact was concerned because the fractures were located near the passenger's side air bag area. the vehicle was not repaired. the approximate failure was 58,000.

2009 chevy silverado crew cab passenger dash cracked right in between airbag. really concerned if airbag is engaged/deployed the dash will interfere or cause harm or bodily injury due to cracked dash pieces to become projectiles into the cab. filed complaint with chevy gmc they wont fix it under warranty but will charge a goodwill fee. prices vary from dealership to dealership depending on location. i am very concerned that this is a mass phenomena and a safety hazard. *tr

Tl* the contact owns a 2009 chevrolet silverado 1500. the contact stated that the door handles detached from the vehicle without warning. the vehicle was taken to al willeford chevrolet (1603 us-181, portland, tx 78374, (361) 444-0250), but the cause of the failure could not be diagnosed. the door handles were reattached to the vehicle, but the failure recurred numerous times. the manufacturer was notified of the failures and stated that the vehicle was not under warranty. the failure mileage was 58,000. *tt

1.) i have noticed that i have two cracks on my dash board 2ft 8"inches apart . 2.) my main concern is the crack on the left side of the passenger air bag 1"inch long into the air bag compartment grove. 3.) i have only 2,189 miles on my truck. *tr

The entire underbody, including rockers, inner door panel frame, tailgate area, engine bay area, and brakes, control arms, struts is rusted over.

Cracked dashboard - typical of gm/chevrolet trucks and suv's no accident or other trauma involved

Tl* the contact owns a 2009 chevrolet silverado 1500. the contact stated that while driving in reverse at 2 mph, the rear bumper bent severely after crashing into a rail. the contact stated the dealer nor manufacturer were notified of the failure. the contact did not mention if the police were called or if there were any injuries. the vehicle was not repaired. the failure mileage was 4,900 and the current mileage was 5,000. the vin was unavailable.

My dashboard has multiple cracks in the dashboard, and my vehicle stays in a garage with the windows cracked to prevent overheating. i have had these cracks since my vehicle was under warranty and gm will not replace it. if i want it fixed i have to pay out of pocket. i have major concerns with the dash turning to shrapnel if the airbag deploys. my vehicle is under the takata recall, as well. the dealership has no concerns with this issue. they have no idea when they can fix my airbag.

Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6) i own a 2009 chevy pickup with a extended cab when i drive down the road the doors shutter and feel like they are going to open the dealer is saying there was a national recall for striker plates they put them on with no change i am afraid to put my kids in this truck because the doors might open and gas pedal doesn't seem to respond correctly [xxx] *tr

I have a 2009 chevy silverado 1500 crew 4x4. i recently had collision backing out of a parking space. i collided with a toyota camry backing out of a space on the opposite side aisle. we basically hit rear corner to rear corner. my complaint is the extent of damage to the truck on such a low speed collision. visual damage: right bumper end (3 piece outer bumper) is bent in and up slightly. rear of bed side panel is bent in and up slightly rear light is cracked there is a dent(buckle) in the bed side panel above the wheel well, about the size of a hand. 3 estimates: (1 dealer, 1 private shop, 1 gm preferred collision center) parts needed; new rear bumper new bumper re inforcement new tail light new truck bed side panel.(yes, the whole side panel!) estimates for damage repairs; $2600 dealer $2600 private $3200 gm authorized collision center about 50/50 parts & labor this does not include a trailer hitch brace that is most likely bent. due to liability of potential failure, all say if this even looks damaged, will require replacement. add $400. dealer and gm collision center gen mgr say the bumper design of the new silverado body style "sucks"! the center section of the bumper can take direct, flush ipact just fine. the end sections will be destroyed in even a low speed impact. the killer is the damage to the side bed panels. because the rear of panel is a single wall of sheet metal, un reinforced, it buckles like fabric at even the lightest touch. you could bend it in by hand if you push hard enough. since there is no way to pull out this panel due to its un reinforced sheet metal design, the most cost effective repair is to replace the whole panel. they sell the truck cheap! they make a fortune on replacement parts because of the cheap design quality. word to the wise: get the rear backing sensors! it will save you $3000. ...