Problems with 2006 Chevrolet Silverado 1500 STRUCTURE

Tl* the contact owns a 2006 chevrolet silverado 1500. the contact stated that the undercarriage was rusted. in addition, the brake and steering warning indicators illuminated. the vehicle was taken to cape cod carz (153 corporation st, hyannis, ma 02601, (508) 778-2279) where it was diagnosed that the frame needed to be welded. the vehicle was repaired, but the failure recurred. the manufacturer was not contacted. the failure mileage was approximately 80,000.

Frame and suspension components excessive rusting to the point of failure. leaf spring shackle failed last year, causing leaf spring to put a hole in truck bed while driving. brakes lines rusted to failure last week and caused near brake loss while operating. had to use e-brake to avoid hitting my garage. cross members supporting shock failed. gas tank about to fall off due to rust failure. cannot drive truck. brakes no longer function and truck is unsafe due to frame being compromised.

Tl* the contact owns a 2006 chevrolet silverado 1500. the contact stated that the frame, body, and brake lines were all rusted out. best chevrolet (128 derby st, hingham, ma 02043, (781) 347-1886) was contacted and stated that there was no recall. the manufacturer had not been contacted. the failure mileage was 212,000. *tt*jb

There is extreme frame rust causing the spare tire mount to become detached from the frame while driving along the highway. fortunately this happened on a secondary road in south west virginia. the shock absorber was the only thing that held the spare tire mount from coming completely loose from the truck. after inspecting the frame, there is excessive rust on the main frame and one of the cross members is nearly rusted through. this truck is nine years old and only has 63k miles. i have the truck at the dealership for them to see if it is safe to drive i am awaiting to hear from them to see if gm is going to help me with this matter.

Tl* the contact owns a 2006 chevrolet silverado 1500. upon inspecting underneath the vehicle, there was extensive rust and corrosion on the brake lines. the contact also indicated that the brake lines prematurely fractured. vehicle was not diagnosed or repaired. the manufacturer was notified of the failure. the approximate failure mileage was 87,000. updated 11/04/15*lj updated2/2/2016*js

First off there's very little snow here so the body and frame isn't rusting out because of that but its definitely rusting very bad the brake lines have rusted completely in half the transmission has went out twice the oil gauge don't work there have been times the motor knocked but then smoothed out again i've been a chevy fan my entire life but the company isn't up to standard's of the consumers in my book if your asking 35000 for a [xxx] truck it should last a long time with no issues. information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6). *tr

while looking over my truck prior to inspection i discovered three cross members totally rusted thru. the are also the main supports for the gas tank and the shocks. i have been trying to find replacement parts and the more i look the more i hear how common the rusted cross members are. i went to the local dealers parts dept. and when i asked for cross members he told me which ones i needed and pointed them out on an illustrated brake down. after the truck bed was removed i noticed the emergency brake cable is rubbing against the plastic gas tank and is just about wore thru the tank to about the thickness of a plastic sandwich bag. the cable has also rubbed against it's support bracket almost all the way thru as well as into the cable. *tr

Tl* the contact owns a 2006 chevrolet silverado 1500. the contact stated when the brakes were depressed, after starting the vehicle, the brake pedal extended to the floor. the dealer diagnosed that the brake line and fuel lines were covered with rust. the entire frame was rusted as well. the manufacturer was not contacted regarding the failure. the vehicle was in the process of being repaired. the failure and current mileage was 48,000. rvk

Tl*the contact owns a 2006 chevrolet silverado. when the vehicle stopped the contact stated the steering wheel became extremely loose. the contact inspected the vehicle and noticed a crack on front passenger side frame. the vehicle was not taken to the dealer for diagnostic testing. the vehicle was not repaired. the approximate failure mileage was 130,000.

Tl* the contact owns a 2006 chevrolet silverado 1500. while driving approximately 10 mph, the engine stalled and the vehicle restarted. there were no prior warnings. the vehicle was taken to an authorized dealer who stated there was a wire shortage underneath the dashboard area. the vehicle was not repaired. the manufacturer was not made aware of the defect. the approximate failure mileage was 60,000. updated 08/31/11 *bf the consumer also stated the rear passenger door fell off. updated 09/01/11

Steering column felt loose - dealership greased it - it appears this will be an every 10,000 miles expense. dealership refuses to admit the beam shake exists that i have just looked up and says they do not know anything about it. this causes the mirrors to be unusable. power steering pump is making noises while turning the wheel all the way to one direction. lifters are clattering all the time while driving the vehicle. there is a clunking noise while making a right turn. *jb

Paint corroded around 3rd brake light dealer (chevy) where purchased is out of business. paint default? *tr

Dt*: the contact stated while reversing at 2 mph, the rear bumper struck a tree and collapsed without warning. moderate vehicle damage was sustained. the police were not alerted. the dealer and manufacturer were notified.

I bought a 2006 silverado ext cab lt3 at the end of february 2006. in march headliner came down. replaced two weeks later. six weeks later headliner came down again the second time. replaced headliner one week later. two days after replacing headliner, it came down the third time. i contacted area rep to have him research the headliner issue (which i already went to two other dealerships and they are selling these trucks with the defected headliners and knowingly selling them). i waited a full month then went for another replacement which took two weeks to come in. one week later headliner coming down again the 4th time. area rep said he put in a tsb to show it is a defect that the headliners are cut too short. i checked on nhtsa and no tsb's are listed about a silverado headliner. people haven't noticed this because it isn't obvious. you have to look at the top of your open doors where the headliner meets the rubber gasket and you will see the cut of the fabric of the headline and the molded headliner piece with it. i've called area rep and it's been 3 days and no return call. i was told it has nothing to do with the factory sunroof either. if the factory knows the headliner's are defective why do they keep sending the ones that are defective instead of waiting till the right ones come out? *jb

On august 13th, 2008 i went to darryl burke chevy to consider buying a new truck and trading my 2006. during the trade in appraisal, the sales manager ask if the vehicle had ever been in an accident? i informed that no it had not. he said the tire, safety, and parts label vin did not match the vin in the windshield. i looked and witnessed the same information. the sales manager said that this would drastically effect the trade in value of my vehicle because it appears that replacement parts have been used. while researching this issue, i found that this must have occurred in the manufacturing process because there are 2 other vehicles which were shipped to other states that have the same problem. they have the labels on them that should be on my vehicle. the national insurance crime bureau has examined the other vehicles and determined that the manufacturer caused this mishap. i need to know if nhtsa can help with this issue because obviously most any dealer is going to recognize the discrepancy and may result in a depreciation in the value of my vehicle. the following vins appear on my vehicle. windshield , safety label , part label match windshield, tire load label . thanks for any help. *tr