Fuel lines have rusted. engine light came on. car is now parked safely. pending repair. inferior materials from chevrolet on this car. many on chevy blog with the same problem.
When i turned off my car recently, i could smell gasoline. i could also smell it when the air conditioning was on. i took my hhr to sweenybuick/gmc, and they pointed out that two fuel lines were rusted through and i was driving my car under dangerous circumstances...some of the gasoline was leaking close to the muffler. my service agent said a fire could have easily started. the mechanic replaced my fuel lines, and then told me that he has had to replace fuel lines in other chevy hhr's and chevy colbalts. at no time has gm ever notified me that my fuel lines can rust through, and that other cars have had the same issue: hhr or cobalt. however, this dangerous rusting has occurred in others. i went online and found out that others have experienced rusted fuel lines, and some have attempted to replace the lines themselves. a recall should have been issued. hopefully no one will die in a tragic fire caused by gas leaks. i could smell the gasoline both when driving (especially with the air conditioning on, and when using the key to turn the car off. however, when looking underneath the car, i did not detect gas leaking from underneath, and i believe this was a slow leak, because my gas gauge did not show a dramatic loss of gas. when i called chevrolet customer support they reported it was a known issue but no recall had been issued.
I put my 2008 hhr in the shop for a brake issue and mentioned to my mechanic that i smelled a faint smell of gasoline to check it out. he called later and told me the brakes were a minor issue but the gas smell was the major issue. the gas line was rusted out in more than one place and i was leaking gas all this time. my story about the gas line is almost word for word the same as a prior complaint on this site. this is a highly dangerous issue and apparently not an isolated one. $ 1000.00 in repair but my safety as well as my family's is at stake. my mechanic recommended that i not get into this car until this repair was made. imagine my surprise when i read someone else had the exact same problem on the same type car.
My 2008 hhr panel ls has a fuel leak and it is located on the driver side just in front of the rear left car. after investigation i believe it is rusted. i understand chevy put a sleeve around the fuel line for whatever reason and living up north it has trapped water and rusted. the fuel line is near the exhaust and i fear it might ignite or possibly trap myself or a drive in a flaming vehicle. can you tell me if this problem is ongoing and has been recalled.
Fuel lines rusted and leaking. leak located on drivers side just before rear tire. upon examination it appears that the two fuel lines are wrapped with insulation of some sort due to the lines proximity to the exhaust. this insulation has been trapping moisture for years causing the oxidation of non stainless steel fuel lines. this dangerous condition was noticed while the vehicle was stopped. i have taken the vehicle to a mechanic and have been told that the lines must be replaced which will cost approx 650 dollars. the mechanic informed me that he is familiar with this common safety hazard attached to this model. i also have now read other complaints regarding this dangerous problem. i strongly suggest that the nhtsa use its considerable influence with the manufacturer of this vehicle to enact a safety recall for this hazard on this model and all vehicles that may have this defect. this safety violation has been reported to your organization, to chevrolet dealerships and to general motors' chevrolet division for years and those notifications have all been ignored. will it take multiple horrendous tragedies before somebody does the right thing. does an american car company need another ford pinto-like (aka "pintorch") negative publicity campaign on its hands?i i cannot fathom why a company that issued a recall for a plastic latch for a dashboard door and has scoffed at folks for notifying them of this very preventable safety hazard.
Fuel line leaking, near fuel tank under heat shield, between exhaust pipe and body part. the vehicle was parked.it appears that the exhaust had repeatedly smashed the fuel line, overtime.
Takata recall. my 2008 hhr is leaking gas from the fuel line by my rear drivers side tire. the leak starts when i start my car and ends within 30 minutes of the car engine being turned off.
I was told by a neighbor that fuel was leaking from the rear bottom of the car. i came home and looked under the car and saw that fuel was leaking from the gas line next to the muffler.the vehicle is now parked in the driveway.
The fuel line was rusted through due to years of the wrapping around the fuel line getting wet and not being waterproof material. it's costing 900 to have fixed. i'm sick and tired of all the issues with this vehicle. i have under 100,000 miles on my vehicle and get routine maintenance done on time. i know cars don't last forever but this seems like a common issue with hhr models and should be recalled.
The fuel line in my 2008 hhr chevy wagon, coming from the rear fuel tank is pressurized by a fuel pump. just in front of the rear driver's side tire, it undergoes a 90-degree bend. this past weekend, it failed, most likely due to corrosion, and gasoline was being pumped out of the tank at a very high volume. this is the third gm product that i have had this happen to in exactly the same spot, the other two were saturn ion sedans. my mechanic told me yesterday that this is a recurring issue for gm fuel lines. i am very fortunate that the leak did not cause a fire- it was a large pool of fuel under the car! (whenever the ignition is turned on, it appears that the fuel pump is supplying pressurized fuel to the line. the tow truck driver yelled at me to turn the key off after i got it out of the driveway! it was gushing gas! the nhtsa should consider this a serious safety issue. ($100 to fix, not bad for an old car.) thanks.
Fuel line is unsafe and fire hazard. noticed a leak around rear door. the line is made of cheap steel, not something like stainless steel and next to the exhaust pipe. could cause both a fire and explosion. this is a recall repair for gm.
This is a very well taken care of vehicle. the design and placement of the fuel lines are near the exhaust and wrapped in heat protection which causes condensation and the building up of moisture to rust out the fuel lines. they begin to leak right next to the exhaust which is a fire hazard that chevrolet should take care of before someone gets hurt.
Rusted fuel line leak in front of rear drivers side tire appeared to have rusted from the fire protection the lines were wrapped in to protect lines from the heat of the exhaust pipe from factory. strong gas smell coming from rear of vehicle and interior. vehicle was driven for a week until noticed smell and complications on cold starting vehicle. this is very dangerous and it is very unsafe if the lines were stainless steel from the factory we would not have to try and jump through hoops for a vehicle that is unsafe it should be mandated that fuel lines brake lines etc should all be made of stainless to resist road salts and rust
Fuel line rusted and leaking near rear driver side door/tire (next to gas tank). i have seen numerous other complaints online regarding the same issue in hhrs. from my research, it appears that the routing of the line combined with the heat shielding lead to moisture trapping and corrosion more quickly than expected.
Gasoline leaking from drivers rear tire area. caused by rusted fuel lines. the fuel lines are located next to the muffler. very dangerous situation. i took it to chevrolet dealership and was told over $1000 to repair this fuel line. spoke with the service technician and he said that gm specifically states no warranty on fuel lines in areas of the country that use salt and sand to treat the roadways. i live in massachusetts and we use sand and salt on the roads. gm is aware of this rusted fuel line problem and will not recall and replace.
Fuel leak on car. noticed problem starting car and then a small puddle of gas under car after car was parked.
Tl* the contact owns a 2008 chevrolet hhr. the contact stated that while driving at 70 mph, the accelerator pedal was applied but it went to the floorboard. additionally, the contact stated that there was an abnormal odor of fuel outside the vehicle and noticed fuel was leaking from underneath the vehicle. the vehicle was taken to an independent mechanic. the local dealer was not contacted. the vehicle was not diagnosed or repaired. the manufacturer was not notified of the failure. the failure mileage was 101,000.
On july 31, 2017 i noticed a gas ordor coming from the car , when inspected i notice a gas leak on the back drivers side. looking forder into the matter the car was jack up to see we're the leak was, the fuel lines were in a terrible shape, rusted out, which then created a crack and fuel was leaking. i believe this should be a safety recall, it is absolutely dangerous big fire hazard . we did get the car repair and the fuel lines were replaced.
Started getting a gas smell in the garage when comming back home. today i noticed that it was dripping gas from under the driver side passenger seat. fire hazard. this car is only 8 years old, have never had another car that had a fuel line leak. leaking raw fuel to the ground when running luckily i saw it and will not drive the car till i get it fixed.
I noticed strong gas smell while car is running, exhaust making funny sound. fuel line leaking on drivers side rear, right next to exhaust pipe. this could have been very serious injury if car had exploded or caught fire!
Starting smelling fuel about 2 months ago and now it's really strong. looks like the line is rusting out near rear tire. i would think that is very unusual for a vehicle that is only 9 years old. after researching online i am finding a lot of hhr owners having the same issue. this should be a recall in my opinion and is dangerous i would think.
I bought this vehicle new...it is now 8 years old...170,000 miles ...it is driven in the northern il area mchenry county ...i put about 80 miles per day on the unit...for the past 4 months my fuel mileage has dropped from 26 mpg to 22mpg...so i tuned up the unit and the mpg remained the same...on 11-16-2016, i was driving down route 12 headed home ,my right rear tire sensor came on so i pulled into a best buy parking lot to check the tire, it might be going flat. as i was down on the ground looking for a nail in the tire , i saw a wet spot on the pavement in front of the left rear tire... i went there to check out what that might be and it was fresh gasoline...then looking under the vehicle i saw a pulsating flow of gas coming from the steel fuel line mounted to the bottom of the floor at a plastic retainer holding 2 fuel lines coming from the fuel tank headed to the engine along with 2 brake lines...i drove the hhr home and inspected the fuel line carefully... it was rusted completely thru inside the plastic line retainer...the retainer seems to be the problem...it catches and holds road salt inside the retainer...it took 8 years to rust completely thru the fuel line...a great fire hazard...i'm very lucky that my tire sensor made me look under the hhr and see gasoline leaking... i called gm customer service and they will not except responsibly for rusted fuel lines... its not under warranty...i told them that it took 8 years to rust...they said that it has 170,000... it past its life span...it's 8 years old...what do i expect...i told them that i expect fuel lines to last for ever... it's the 21 century...interesting the 2 metal brake lines in the same retainer are in perfect condition...they seem to be powder coated, so why not the fuel lines. 2 things that we need, is to stop the vehicle, and no gasoline leaking on the pavement ...i have pictures of the fuel line. *tr
Fuel lines in front of drivers side rear wheel completely corroded thru. partially due to heat shroud, rubber covered with foil, installed due to lose proximity to exhaust pipe. return line started leaking,pressure line broke in half during removal. chevy disavows all responsibility although the rest of the lines are not rusted. heat shroud contained road salt, sand and gravel when removed. corrosion was exfoliate in nature. on line research shows at least one instance of a hhr catching fire due to this. problem was discovered after smelling fuel and discovering fuel leaking under vehicle. author of report has been working on cars for 45 years and has held an a&p certificate for over 40 yrs. have never seen 8 year old fuel lines in this condition. black coated brake lines running next to fuel lines were completely unaffected. as previously stated there are many texts online concerning this issue, all received the same lack of concern from gm, including their customer service line.
I started smelling gas inside/outside of vehicle after shutting it off. when starting the vehicle the exhaust sounds rough. i took my vehicle to an independent mechanic and a chevrolet dealership and found that the gas lines near the rear driver side tire are rusted and have also damaged my exhaust manifold which is also causing the vehicle to sputter when accelerating. because the problems are due to gm's poor job of designing this unsafe vehicle this issue should not be the vehicle owners responsibility, it should be recalled.
Steering shaft u joint rusted and broke in drive way
Started smelling gas smell when walking up to vehicle after sitting...including smell within the cabin. did a little research and found many complaints about rusted gas lines near the rear driver side tire and sure enough when looking there i could now see on the ground where gas was dripping. the lines are partially covered with what seems like a heat shield...yup...my guess would be because the hot exhaust pipe runs near it. the heat shield i believe seems to hold moisture against the lines and condensation and i'm guessing it defeats the purpose when the line is now rusted through and is dripping gas near the exhaust pipe. very poor and dangerous design.
Since2006 fuel lines continue to rot out spraying fuel on exhaust
Tl* the contact owns a 2008 chevrolet hhr. while in park, the vehicle failed to start intermittently. in addition, the contact noticed fuel fumes emitting from the vehicle fuel was leaking from underneath the vehicle. the failure recurred on numerous occasions. the vehicle was taken to an independent mechanic who diagnosed that the fuel lines were corroded and needed to be replaced. the vehicle was not repaired. the manufacturer was not notified of the failure. the failure mileage was 83,000.
My chevy hhr developed a leak in the fuel line - just behind the rear driver's side tire. when looking this up on line, i was shocked at how many others had reported the same complaint. the leak was only visible to me when the car was parked on an incline (spotted 3-25-15). however, it had trouble starting for about 2 weeks prior - the dealer confirmed this was due to gas leaking out the line. the fuel line and the canister purge line both needed replaced. *tr