Problems with 2010 Chevrolet Equinox STRUCTURE

I started noticing that water was soaking the floor mat on the drivers side of the car after it rained or i went through a car wash. i took the car to a repair shop and they notified me that the bottom of the car is not welded properly from the manufacturer, so the space where it should have been welded together has left holes on both sides of the bottom of the car. these holes provide an area where water leaks into the car and continuously soaks the floors. there is also information from gm that states other 2010 chevrolet equinox cars have had this same problem, so it is clearly a manufacturing problem.

Tl* the contact owns a 2010 chevrolet equinox. while driving approximately 40 mph over a pothole, the rear passenger tire became flat. the contact used the spare tire and drove the vehicle to a tire facility to purchase a new tire. the mechanic discovered that the frame and components were severely rusted and the control arm was fractured. the vehicle was deemed unsafe to be driven. the vehicle was not repaired. the vehicle was not taken to the dealer for diagnostic testing. the manufacturer was not notified of the failure. the approximate failure mileage was 130,000. the vin was unavailable.

2010 chevrolet equinox. consumer writes in regards to front and rear rusted subframe. *ld the consumer stated the front and rear subframe was completely rotted. the rocker arms on both sides were extremely rusted and soft. the bottom of the doors were also rotted. the manufacturer was notified. *js

Tl* the contact owns a 2010 chevrolet equinox. the contact stated that the vehicle was able to be in motion without the key in the ignition. also, when the gear was shifted into park, it was not fully in gear so the contact constantly had to check. the vin was excluded from nhtsa campaign number: 16v502000 (electrical system, power train). in addition, water entered various areas of the vehicle and the electronic stability traction control warning indicator randomly illuminated. the vehicle also rolled backward and forward without warning and the hatch came down unexpectedly. the vehicle was taken to the dealer for diagnostic testing. the manufacturer was notified of the multiple failures. the failure mileage was not available.

Rust on bottom of door panels, also hatch door car is oiled annually,

Vehicle is 5 years old and there is rust on the inside lower door hem on three of the 4 doors. it has always been housed in a garage in the evenings and washed with relative frequency. gm has issued a notice to fix this issue but for vehicles housed in canada only not in the us. it is obvious this is a design flaw that gm is correcting in canada but not the us.

Incident occurred: june 30, 2015 a tractor trailer was passing another vehicle and proceeded to come into the left lane. i had cruise control engaged. the truck came over admittedly at a speed that was going slower than the rate of speed i had on my cruise control. when i went to apply the brake, i felt as though my car was not decelerating enough based on the pressure i was applying to the brake. i quick checked my side mirror- i was unable to go around the driver because a car was next to me and i checked my rearview mirror to ensure i was not going to be rear-ended as well- knowing i was too close and going to collide with the truck driver at this point. i applied as much pressure as i could to the brakes to decelerate but unfortunately still collided with the driver. my air bags did not deploy- despite this, it allowed me to see my mirrors immediately following the incident so that i could safely coast to the shoulder of the pa turnpike without disrupting traffic. my 2 concerns: was braking faulty when cruise control is engaged? also- my air bags did not deploy.

Chevy was stopped at a traffic light and was approx. 30 feet behind another vehicle and the driver had his foot on the brake pedal. the chevy suddenly accelerated, driver tried to stop vehicle by stepping harder on brake pedal, he swerved to the left to avoid hitting vehicle in front of him, but still hit vehicle with extensive damage to the chevy. *tr

Gm, used a felt like material on the 2010 equinox between the front fender and the fire wall for sound deadening . i have checked out their new models and they are using it on all of them now [trucks,cars,suvs]. the problem is that this material stays wet, collects salt, mud, etc. as we drive on roads where salt is used in the us and canada i have removed on the passenger side so far. the fire wall and fender both have serious rust which will lead to a perforation of the passenger cabin. there must be a better material to use for this purpose that will not stay wet. i have contacted gm but they did not seem too concerned about the issue. hope you folks have better luck then myself. please note we live in canada and arizona about 50/50. *tr

The chevrolet equinox instrument panel top pad has a integrated compartment in the center. the compartment has a bright chrome latch for opening the compartment. the latch has a very reflective surface. when driving south east the sun reflected off the latch blinding the driver even with sunglasses. view of the road was lost and the seat had to be repositioned to move the drivers eyes from the reflection. photograph is available. *tr

The back hatch lock will not release on my 2010 equinox to open the hatch. it started with a difficult try to open it. now it will not open at all. i am bringing it to the dealer tomorrow (it is out of warranty over 36,0000 miles) this hatch is not open every day. in reality it is open only about once a week, so it shouldn't have broken. *tr

Car made noise and engine started to stop. pulled off to side of freeway, turned off key and car burst into flames. car is a total loss, due to the fire damage. *tr

As i approached an intersection, i hit the rear end of a ford 150 pick up truck that was in the intersection waiting to make a left turn. my approx speed was 15 miles per hour. i had my seatbelt on, i was taken by ambulance to the hospital - my evaluation revealed sprain/strain to my neck, fractured right ankle, and chest wall discomfort related to the seat belt. the car was totaled --- the airbag did not deploy. *tr

Mildew smell in car from air vents, and also stronger smell from window wells when windows are rolled down. first, dealership replaced cabin air filter. didn't correct problem. two weeks later, took it back and they determined drain holes in all four doors were "clogged" and mildew was building up inside doors. dealership claims they took apart all doors, cleaned and sprayed inside with disinfectant and cleaned out weep holes in doors.- all within two hours. they told us to "keep an eye on the weep holes you'll probably have to keep having this done." this is unacceptable on a brand-new car. it causes a terrible smell, and an unsafe respiratory environment for passengers. *tr

+2010 equinox liftgate goes all the way up, but in a couple of seconds slowly comes back down to about 3/4 open. i tried everything to correct the problem. could not find anything on the internet of anyone else having this problem. *tr

In new chevy vehicles there is a center storage compartment located above the center console. this is held down in place by a simple push button. the button however is problematic as in some trims it is a chrome feature. in sunny condition, the reflection from the chrome push button reflects into the driver's eyes. this could lead to possible dangerous driving conditions. *tr

Hard to put gas on this vehicles and tend to eject gas pump trigger when putting gas. roof woobly not strongly constructed. *tr

Tl* the contact owns a 2010 chevrolet equinox. the lower body molding detached from the front wheel opening, and then to the rear wheel opening . his leg was cut as a consequence because the corners of the doors became extremely sharp. he sent the manufacturer pictures of his injuries. he was referred to the dealer. no repairs were made. the current mileage was approximately 8,400. the failure mileage was approximately 2,000. updated 11/10/09 *cn updated 11/13/09