Fuel overfills and spills when fueling. *tr
Fuel spills out at every time i fill up. *tr
Fuel spills out of fill tube, after pump shuts off. *tr
2006 rubicon with 40k miles. fuel sprays out from the gasoline fill tube and runs down the outside of the vehicle onto the pavement every time the vehicle is refueled. the dealership says the fuel tank must be replaced to correct the issue. it doesn't make sense to pay for a new fuel tank with the same defect. this is apparently a widespread issue and should be recalled. *tr
While fueling vehicle at gas station, fuel splashes out before fuel pump shuts off at fill up. regardless of gas station or speed at which pump is set at fuel always spills unto vehicle and ground. it is apparent that the fuel tank's roll over check valve is at fault.
Fuel spills out during regular pumping at gas station. this happens during the end of the pumping when the tank is almost full. gasoline will shoot out of the filler spout and onto the ground. *tr
Fuel always spews out of tank when filling up. will not activate pump auto-shut-off. extremely dangerous condition! *tr
Fuel spits out of tank when filling no matter how you fill tank . will spit fuel on ground on auto fill or manual fill any station. have had fuel on my shoes at times must stand back around corner of jeep. *tr
1. refilling fuel tank. 2. once tank is full and pump handle turns off; a surge of fuel is spit out of the fuel filler, onto the side of the vehicle and onto the ground. this happens every time i refill the tank. 3. no corrective action has been taken. *tr
At every fill up on my 2006 wrangler rubicon gas spits back out once it's full and about a 1/2 gallon of gas spills everywhere after the automatic stop function on the pumps clicks off. *tr
Tl* the contact owns a 2006 jeep wrangler. the contact stated that when refueling, fuel would leak onto the ground. the dealer repaired the failure by replacing the fuel tank but the failure recurred. the manufacturer was not contacted. the failure mileage was 16,000 and the current mileage was 40,000.
I have a 2006 jeep wrangler unlimited, and almost every time i fill up the gas tank it overflows, often spraying a significant amount of fuel before the pump shuts off. this did not happen when it was new, but has been happening off and on, getting progressively worse, for the past 3 years. i believe this presents both a fire hazard and an environmental hazard, and i know that many other wrangler owners have observed the same problem. *tr
Every time i fill up my gas tank, it will overflow and leak gas all over the ground and along the side of the car. *tr
When refueling our jeep the pump does not shut off in time spraying fuel all over the side of the vehicle and ground. to fix this the dealer wants to replace the fuel tank. this is a very common across the board chrysler problem that they are not owning up to. *tr
Almost always get a "splash back" when fueling vehicle as gas station! very hard to listen and decipher if full, i try to guess how many gallons i need to fill up. spills out gas on the vehicle, on the ground, and on your feet! i have read that many of these vehicles are having the same complaint, without a recall, and it is not the gas pumps problem. *tr
Gasoline overflows every time when filling tank on 2006 jeep wrangler. it is ridiculous that this dangerous issue has not been resolved. *tr
When refueling my 2006 wrangler jeep gas surges out of the tank prior to the pump shutting off. i have not measured the amount spilled but it is enough to create approximately a 24-36" diameter wet spot on the ground. this happens every time i fill my vehicle no matter which filling station i use. this seems like a significant safety and environmental hazard considering it splashes on my arm and clothing if i am holding onto the pump handle or standing within arms reach of the nozzle and the spilled fuel is becoming a ground or water contaminate one way or another as it is soaked up or washes away.
Fuel spills out on me and surrounding area when filling the gas tank. this event happens every time i fill the tank. i cannot use the automatic fuel shutoff on the fuel nozzles as gas is spilled (about .5 cup) on the surrounding area. this is a fire hazard. *tr
When filling the gas tank in my 2006 jeep wrangler tj, the fuel overflows and spills/splashes all over the side of the vehicle, and ground. jeep knows about this issue but refuses to do anything about it. *tr
The problem started with gas shooting out of the filler neck prior to the fuel pump automatically shutting off. this was repeated at every fill up at numerous gas stations. for the past 8 months i can not fill the fuel tank without the fuel nozzle repeatedly shutting off. i can only add fuel at an extremely slow pace or not at all. it has become so bad that i now carry a gas can, it's faster to fill the can then pour it in the tank! tt
Gas tank overfills at every fill-up. gas shoots out all over and has gotten on clothes on several occasions. this seems dangerous. *ln
during fueling, when the fuel pump nozzle automatically stops the flow of gasoline , fuel surges back through the filler tube and vigorously splashes out on the side of the vehicle and anything or person within 2 to 3 feet of the fuel filler. this occurs every time the fuel tank is filled and has drenched the person filling the vehicle from the waist down with gasoline on two occasions. has spilled fuel on every fillup (at least one cup), despite precautions (slowing filling rate). manufacturer and dealer have done nothing to correct this problem, this happens almost every time i fill up. *tr
When filling the gas tank the gas overflows in a spray or stream without tripping the pump shutoff. it also at times will only fill when filling extremely slow. *tr
When filling up my gas tank, fuel blows out of the (gas fill up opening) when...it almost reaches full (about 6 gallons to go). in the last year it done this about 15 times. *tr
When filling my gas tank at any gas station, the gas spills (or actually shoots out) out. this is a serious safety and environmental issue. i just took it to the shop after getting gas all over me. i spent $100 on diagnostics. i have heard that this is a known problem and jeep/chrysler is too cheap to cover it by recall. i've heard of a group that is talking to tort attorneys so i will look into that next. *tr
Fuel spray from filling vehicle up. different gas stations all produce the same result. if i set the auto fill on the pump or if i hold the pump handle, fuel will spray out of the fill neck and onto the vehicle, ground or myself. *tr
Jeep spills out large amount of gasoline every time it is filled up. *ln
When refueling the vehicle, gasoline is spit back out of the filler neck when the automatic shutoff releases and the tank is full. if the filler nozzle has splash guard, spilled fuel runs down the side of the vehicle on to the ground. otherwise fuel is shot out up to 5 feet and cover anything or anybody within the radius of the spill. no remedy found, it always happens. *tr
Gastank overflows when filling. *tr
When filling up gas tank, the fuel spits out upon a full tank. this happens every time i fill up at any gas station. *tr
I have a 2006 jeep wrangler that is shooting gasoline out of it after it is filled up with gas. basically, after the fueling is complete and the pump clicks off, gasoline shoots out of the filler neck and all over the side of the car, the ground, and the pump. it is only a matter of time until this defect causes a fire at a station or gets somebody killed. jeep is refusing to repair this problem. there are quite a few jeep owners who are reporting this same problem. *tr
Fuel spilling at every fill up, from reading on the internet it seems to be a very common problem with jeep wranglers. it happens at every fuel station and doesn't matter if the nozzle is half in or totally in. *tr
I have a 2006 unlimited jeep wrangler and a couples years ago, while my car was still under warranty, the gas tank started overflowing, the pump did not stop and gas would get all over the car, my clothing, etc. the dealership then replaced the entire gas tank. recently this problem began again and i had to contact the manufacturer directly and then the dealership to get this fixed. i ended up paying approximately $222 to get a new gas tank again. when i went fill up the car after picking it up from being "supposedly" fixed i realized that it was not fixed and gas was all over my car. it seems as if this is a recurring problem and replacing the gas tank is a short term fix or no fix at all. needless to say, i have to bring my wrangler back to the dealership again. *tr
The gas tank overfills each time i fill it up. when set on the automatic gas fill function it over spills. *tr
Fuel spilling during refueling. fuel rushes out of tank when close to full. *tr
It seems a check valve that is part of the fuel tank failed. regardless of gas station, nozzle position or flow rate i always get gas splash back when i fill up the tank. it is my understanding that replacement gas tanks have the same defect that will cause them to fail in a short period of time.
Fuel spills from filler neck upon completion of refueling in my 2006 jeep wrangler. please expand current investigation to earlier model year jeep wrangler vehicles. *tr
2006 jeep wrangler x i recently purchased this vehicle used with 58,000 miles. i discovered a very dangerous condition when filling up with gas. the gas flow to the tank does not properly turn off when the tank becomes full. the first time this happened to me i was sprayed with gasoline on my chest ... nearly missing my face. i thought this was a fluke but it happened again the next time i filled up. i've learned to only fill up the tank half way. i did an internet search and found that this is a very common problem with newer jeep wranglers. it is also an environmental issue as well because gasoline just travels down the jeep and into the ground. i have learned through jeep internet forums that this is a very common issue with jeep wranglers. this issue must be addressed by chrysler through a vehicle recall. there will definitely be deaths/injuries from this if it is not properly addressed by chrysler. *tr
When filling gas tank on 2006 jeep wrangler the gas over flows and sprays out when full. on numerous occasions it has sprayed gas in my face. *tr
When filling a fuel tank it always overflow and fuel spit out. *tr
1. failure apparent since beginning of ownership. 2. fuel spills out of gas tank upon filling the gas tank in a normal fashion. failure occurs every time gas tank is filled completely. gas spills out of tank, over the outside of the vehicle, and on to the ground at the gas pump. 3. no attempts to correct failure at this point. *tr
Every time we fill our gas tank it sprays out all over when full. dealership says we must pay for a new fuel tank to repair this issue. this is a faulty flap inside tank. we will not pay for a new tank since they have the same flap design. this should be recalled. *tr
I've been dealing with this problem for 4 years. while fueling, gasoline will overflow without cutting off. also, it is very difficult to pump a full tank with all of the back pressure caused the neck and gas tank problems. this is very dangerous and needs to be investigated on models later that 2007. *tr
The fuel filler neck/gas tank on my 2006 jeep wrangler has filling problems. any time i go to fill up on gas the pump does not click off in time and gas literally shoots out of the filler neck all over the bumper of the jeep and on the ground. i haven't tried to measure the volume of gas that shoots out each time, but i would estimate at least 6-8oz of fuel. *tr
Filling up gas tank on 06 jeep wrangler gas spilling out of fill nozzle everytime i fill up, wasting fuel dep environmental problems we need recall to get this fixed. *tr
I have a 2006 jeep wrangler and everytime i fill up the fuel tank it overflows and spills everywhere. this could be a major cause for fire or explosion. *tr
A majority of the times that i fill my gas tank it overflows. i put the nozzle in and begin filling the tank and then it clicks off and immediately after the click fuel comes out of the filler and onto my jeep and the ground and my shoes and my hands if they are close to the pump. from what i've read, i'm not the only one with this problem with a jeep vehicle. *kb
Gas tank overflow when filling at gas pump. sprays out of fill tube when filling. *tr
2006 jeep wrangler gas tank overflows every time when filling up the gas tank. sometimes to the point that the gas will spew in the air from the tank depending on the type of gas nozzle that is used. *ln
Fuel blows out from the gasoline fill tube, runs down the outside of the vehicle and spills onto the pavement every time vehicle is refueled. sometimes the fuel blows out with such force it splashes onto whoever is holding the nozzle. the pump nozzle will shut off as the tank is filled but fuel will simultaneously blow out of the fill tube. it does not matter which gas station is used, it happens at every gas station, and has happened in several states. this vehicle has not been modified in any way and has not been in a collision or damaged in any way. the dealer suggested replacing the tank at my expense, but would not guarantee that even complete replacement would correct the problem. *tr